Drawing : - TPC249 Issue :-7 Date : - 10/12/13 CD60 INDUSTRIAL DEHUMIDIFIER OWNER’S MANUAL www.eipl.co.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 CD60 PACKAGE CONTENTS Item Description Quantity 10264FR-US Dehumidifier 1 3086144 Quick release hose coupling 1 3944110 PVC Tube – 3/8” I/D 7.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 INTRODUCTION Designed for a wide range of applications, the CD60 dehumidifier is a rugged, industrial unit which utilizes an energy-efficient compressor and a compact portable design to provide easy efficient drying.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 SPECIFICATIONS MODEL: CD60 HEIGHT: 17” WIDTH: 20” DEPTH: 14” WEIGHT: 80 lbs AIRFLOW: 360 CFM POWER SUPPLY: 110V/ 60Hz/ 1 ph FINISH: Powder-coated Epoxy OPERATING RANGE: 33°F – 95°F REFRIGERANT: R-407c (13 oz) "This product contains fluorinated greenhouse gases covered by the Kyoto Protocol. The refrigeration system is hermetically sealed.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 OPERATION The following procedures should be followed to test the CD60 for correct operation: 1. After unpacking, examine all external features to confirm damagefree shipment. Report all defects and damage at once. Connect the power cable to a grounded 15 Amp electrical outlet. 2. Check dehumidification process as follows: CAUTION: DO NOT REMOVE COVERS WHEN UNIT IS IN OPERATION A. Place unit on a level surface. B. Start up unit by switching to “ON”.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 ROUTINE MAINTENANCE WARNING: ENSURE THAT THE POWER CORD TO THE MACHINE HAS BEEN DISCONNECTED BEFORE CARRYING OUT ROUTINE MAINTNENANCE To ensure continued full efficiency of the dehumidifier, maintenance procedures should be performed as follows: 1. Clean the surface of the evaporator and condenser coils by blowing the dirt out from behind the fins with compressed air. Hold the nozzle of the air hose away from the coil to avoid damaging the fins.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 REPAIRS 1. Should an electrical component fail, consult the Factory Service Center to obtain the proper replacement part. 2. If refrigerant gas is lost from the machine, it will be necessary to use a refrigeration technician to correct the fault. Contact the Factory Service Center prior to initiating this action. Any competent refrigeration technician will be able to service the equipment. The following procedure must be used: a.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 TROUBLESHOOTING SYMPTOM CAUSE Unit inoperative 1. No power to unit Little or no airflow 1. Loose fan on shaft 2. Fan motor burnt out 3. Dirty refrigeration coils 4. Loose electrical wiring Little or no water extraction 1. Insufficient air flow 2. Compressor fault 3. Loss of refrigerant gas Little or no defrost when required 1. Faulty timer 2. Faulty by-pass valve Unit vibrates excessively 1. Loose compressor 2.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 CD 60 SPARE PARTS LIST NUMBER DESCRIPTION 1 Compressor (RGA5467EXA) 2 Compressor Overheat Protector 3 PART NUMBER QUANTITY 3022169 1 N/A 1 Compressor Capacitor 3030908 1 4 Condenser Coil 2026014 1 5 Evaporator Coil 2026074 1 6 Filter Dryer 3020901 1 7 Fan Motor Assembly 3035753 1 8 By-pass Valve 3020814 1 9 Mechanical Timer 3030781 1 10 Hour Meter 3030779 1 11 Rocker Switch 3035914 1 12 Terminal Block 3031460
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 17 Drain tube P-clip 3035697 1 18 Drain Tubing 3014336 25ft 19 Trolley (optional) 1026004 1 20 Wheel 3050110 2 21 1” Starlock Washer 3082601 4 22 Condensate Pump 3160129 1 23 Purge Switch 3036779 1 24 Quick Disconnect 3086144 1 25 Snap Hose Clip 3086135 1 26 Hose Clip Snapper 3086136 1 Spare parts available online www.EIPLDIRECT.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 LIMITED WARRANTY Our products carry a one-year unconditional warranty against any defects in workmanship or material. This warranty will cover all parts and labor required to repair your Ebac product. This warranty is invalid if the unit has been abused, damaged, whether intentional or accidental, or if any modifications have been made to the unit.
Drawing : - TPC249 Issue :-7 Date : - 10/12/13 UK Head Office American Sales Office German Sales Office Ebac Industrial Products Ltd St Helens Trading Estate Bishop Auckland County Durham DL14 9AD Ebac Industrial Products Inc 700 Thimble Shoals Blvd. Suite 109, Newport News Virginia, 23606-2575 USA Ebac Industrial Products Ltd. Gartenfelder Str.
