Drawing : - TPC137 Issue :-7 Date : - 23/11/16 CD30 / CD30E DEHUMIDIFIER (FULL PRODUCT RANGE) OWNER’S MANUAL www.eipl.co.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 UNPACKING Carefully remove the CD30 dehumidifier unit from its transit box and visually check for signs of transit damage. If there is evidence of damage DO NOT attempt to operate the unit, call your supplier for advice. Do not discard the packing; it will be useful when transporting the dehumidifier unit in the future. INTRODUCTION Dehumidifiers remove moisture from the air that is circulating through the unit.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 SPECIFICATIONS MODEL: CD30 CD30E HEIGHT: 300mm 300mm WIDTH: 304mm 350mm LENGTH: 550mm 550mm WEIGHT: 23 Kg 25 Kg AIRFLOW: 150 M3/Hr 150 M3/Hr 240V, 1 ph, 50Hz 240V, 1 ph, 50Hz POWER 360W (max) 460W (max) FINISH: grey epoxy coating grey epoxy coating 85M3 85M3 R134a (170g) R134a (170g) POWER SUPPLY: EFFECTIVE VOLUME: REFRIGERANT TYPE/QTY: "This product contains fluorinated greenhouse gases covered by the Kyoto Protocol.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 INSTALLATION POSITIONING: Position the dehumidifier unit in the center of the room to be conditioned if at all possible. However if a damp patch is particularly apparent the outlet grille should be pointed towards it. NOTE: Both inlet grille and outlet grille of the dehumidifier unit must have clear space around them and not be obstructed in anyway. WIRING: Connect the power mains cable to a 5 or 13 Amp power supply.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 OPERATION The operation of the dehumidifier is to remove moisture from the air by having it condense on the cold tubes of the evaporator coil. The air then passes over the hot condenser coil and returns to the conditioned space slightly warmer and dryer than when it entered the dehumidifier unit.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 WARNING: • • • Due to the high pressures within the refrigeration circuit, under no circumstances must direct heat be applied to the evaporator coil in an attempt to remove the build up of ice. No attempt should be made to cut open any part of the refrigeration circuit due to high pressures and gas involved.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 SPECIAL FEATURES (Where Fitted) Temperature Controlled Defrost The ‘CD30E’ Dehumidifier unit can be fitted with temperature sensitive devices which will operate in conjunction with the defrost control.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 ROUTINE SERVICE WARNING: ENSURE THAT THE POWER CORD TO THE MACHINE HAS BEEN DISCONNECTED BEFORE CARRYING OUT ROUTINE SERVICE. THE SERVICING AND REPAIR OF THIS UNIT SHOULD ONLY BE CARRIED OUT BY A SUITABLY QUALIFIED PERSON. To ensure continued full efficiency of the dehumidifier, maintenance procedures should be performed as follows: Removal of the cover is achieved by means of four screws at the sides of the unit at base level.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 REPAIRS 1. Should an electrical component fail, consult the Factory Service Center to obtain the proper replacement part. 2. If refrigerant gas is lost from the machine, it will be necessary to use a refrigeration technician to correct the fault. Contact the Factory Service Center prior to initiating this action. Any competent refrigeration technician will be able to service the equipment. The following procedure must be used: a.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 TROUBLESHOOTING SYMPTOM Little or no airflow CAUSE 1. Loose fan on shaft 2. Fan motor burnt out 3. Dirty refrigeration coils 4. Loose electrical wiring 5. Control humidistat either set too high or malfunctioning Little or no water extraction 1. Insufficient air flow 2. Compressor fault 3. Loss of refrigerant gas Little or no defrost when required 1. Faulty Timer 2. Faulty bypass timer Page 10 of 16 REMEDY 1. Tighten fan 2. Replace the fan motor 3.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 CD30 SPARE PARTS LIST DESCRIPTION PART NUMBER Product Part Number 1139500 1139525 1013700 1135400 Compressor 3022132 3022132 3022132 3022132 3022132 3022132 Compressor OH Protector 3021519 3021519 3021519 3021519 3021519 3021519 Compressor Relay 3021520 3021520 3021520 3021520 3021520 3021520 By-Pass Valve 3020811 3020811 3020811 3020811 3020811 3020811 Condenser Coil 3020740 3020740 3020740 3020740 3020740 3020740 Ev
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 CD30I STAND & CD30I INDICATOR BOX SPARE PARTS LIST DESCRIPTION PART NUMBER CD30I Stand 1139535 Adjustable Tilt Guide 3050305 CD30I Indicator Box 1139530 Red Neon Lamp 3032272 M16 Gland Type 3032512 Resistor 180K Ohms 3032883 Female Insert Contact Type 3033810 Hood 3033811 Cable Seal 3033813 Female Contact 3033815 Green Neon Indicator Lamp 3034584 Sealing Washer 3035423 6-way Terminal Block 3036810 Page 12 of 16
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 WARNINGS This appliance can be used by children from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the application in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision.
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 Page 14 of 16
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 Page 15 of 16
Drawing : - TPC137 Issue :-7 Date : - 23/11/16 UK Head Office American Sales Office German Sales Office Ebac Industrial Products Ltd St Helens Trading Estate Bishop Auckland County Durham DL14 9AD Ebac Industrial Products Inc 700 Thimble Shoals Blvd. Suite 109, Newport News Virginia, 23606-2575 USA Ebac Industrial Products Ltd. Gartenfelder Str.
