Technical information

AUTOTRONIC CONTROLS CORPORATION • 1490 HENRY BRENNAN, EL PASO, TEXAS 79936 • [phone] • FAX [phone]
www.msdignition.com email: [e-mail]
112
The Multi-Channel Programmable Boost Controllers are designed to be used with the MSD DIS-4, PN 6215, or
DIS-4HO, PN 62151, though it can also be used with MSD single channel ignitions (MSD 7AL-2). The controllers
allow users to program and control a variety of rpm and timing functions ranging from Individual Cylinder Timing to
retards for each gear.
Programming the features of the Controllers can be done with a PC using MSD’s Pro-Data+ software, or with the
MSD Hand Held Monitor, PN 7550 (See Page 60). This software can be downloaded from www.msdignition.com at
no charge.
The PN 6563 features a Fuel Adder circuit that gives you the ability to program the output of up to four additional
fuel injectors.
Note: The programming and features of these Controllers are explained at length in the installation instructions.
These can be downloaded at www.msdignition.com or contact the MSD Customer Support Department
and they will send you a copy (915-855-7123).
DIS-4 MULTI-CHANNEL PROGRAMMABLE
BOOST CONTROLLER, PN 6562
WITH FUEL ADDER, PN 6563
TAN (STEP 3 RETARD) -
DARK BROWN (STEP 2 RETARD) -
PINK (STEP 1 RETARD) - ACTIVATED
BLACK (-)
DARK BLUE (LAUNCH REV LIMITER) -
LIGHT BLUE (BURNOUT REV LIMITER) -
ACTIVATED WHEN CONNECTED TO 12 VOLTS
ACTIVATED WHEN CONNECTED TO 12 VOLTS
WHEN CONNECTED TO 12 VOLTS
- BATTERY NEGATIVE
ACTIVATED WHEN GROUNDED
ACTIVATED WHEN GROUNDED
(4 PIN CONNECTOR)
INJECTOR CONTROL
PN 6563 ONLY
IGNITION
TM
PN 6215
MULTI-CHANNEL
PROGRAMMABLE
CAPACITIVE DISCHARGE IGNITION
TWO STEP (GROUND TO ACTIVATE)
IGNITION INTERRUPT
(GROUND TO ACTIVATE)
BOOST PORT
ORANGE/YELLOW - SHIFT LIGHT
LIGHT GREEN/LIGHT BLUE - CAM-SYNC PICKUP INPUT
VIOLET/GREEN - MAGNETIC PICKUP INPUT TRIGGER
NOT USED
LED
MONITOR
BROWN
BLUE
TACH
OUTPUT
BYPASS CONNECTOR
12-PIN CONNECTOR
BROWN/VIOLET
BROWN/ORANGE
BROWN/YELLOW
TRIGGER
3
IGNITION
12 VOLTS
TRIGGER 4
VIOLET
RED
YELLOW
COIL (-) CHL 3
COIL (+)
COIL (-) CHL 4
DRIVERS
COIL
COIL (-) CHL 1
COIL (+)
COIL (-) CHL 2
BROWN/WHITE
BROWN/ORANGE
BROWN/GREEN
TRIGGER
1
IGNITION
12 VOLTS
TRIGGER 2
GREEN
RED
WHITE
HARNESS
HARNESS
PASSENGER
COIL
NOTE: The vehicle coil harness is cut
about 3 inches from coil connector
and both ends are terminated with
supplied Butt Splice connectors.
This allows the MSD Ignition to be
unplugged and the stock ignition to
be reconnected with the supplied by-
pass plug.
DIGITAL DIS-4
HEAVY RED
HEAVY BLACK
TO BATTERY
TO BATTERY
+
DIS-4 MULTI-CHANNEL PROGRAMMABLE
TO V-8 COIL PACK IGNITION