FCC Test Report Report No. : FR442525 Table of Contents 1 GENERAL DESCRIPTION .................................................................................................................... 5 1.1 1.2 1.3 1.4 1.5 Information.............................................................................................................................................. 5 Support Equipment.....................................................................................................................
FCC Test Report Report No. : FR442525 Summary of Test Result Conformance Test Specifications Report Clause Ref. Std. Clause 1.1.3 15.203 Antenna Requirement 3.1 15.207 AC Power-line Conducted [dBuV]: 0.5321540MHz Emissions 46.86 (Margin 9.14dB) - QP 40.58 (Margin 5.42dB) - AV Description Measured Limit Antenna connector mechanism complied FCC 15.203 6dB Bandwidth Unit [MHz] 20M: 10.05 / 40M: 32.20 Result Complied FCC 15.207 Complied ≥500kHz Complied 3.2 15.247(a) 6dB Bandwidth 3.
FCC Test Report Report No. : FR442525 Revision History Report No. Version Description Issued Date FR442525 Rev. 01 Initial issue of report Jul. 18, 2014 2500-2690 SPORTON INTERNATIONAL INC. Page No. : 4 of 57 TEL : 886-3-327-3456 Report Version : Rev.
FCC Test Report Report No. : FR442525 1 General Description 1.1 Information 1.1.1 Table for Multiple Listing Brand and models that are exactly the same EUT, products with different models only because of market segmentation. NO. Brand Name Model Name Edimax EW-7438RPN, GRP-438N, EW-7438RPn Mini 1 lC lntracom USA lnc. 525558 2 1.1.2 RF General Information RF General Information Frequency Range (MHz) IEEE Std. 802.11 Ch. Freq.
FCC Test Report 1.1.4 Report No. : FR442525 Type of EUT Identify EUT EUT Serial Number Presentation of Equipment N/A Production ; Pre-Production ; Prototype Type of EUT Stand-alone Combined (EUT where the radio part is fully integrated within another device) Combined Equipment - Brand Name / Model No.: Plug-in radio (EUT intended for a variety of host systems) Host System - Brand Name / Model No.: Other: 1.1.
FCC Test Report 1.2 Report No. : FR442525 Support Equipment Support Equipment - AC Conduction and Radiated Emission No. Equipment Brand Name Model Name FCC ID 1 Notebook DELL E5520 DoC Support Equipment - RF Conducted No. Equipment Brand Name Model Name FCC ID 1 Notebook DELL E5500 DoC 1.3 Testing Applied Standards According to the specifications of the manufacturer, the EUT must comply with the requirements of the following standards: 47 CFR FCC Part 15 ANSI C63.
FCC Test Report 1.5 Report No. : FR442525 Measurement Uncertainty ISO/IEC 17025 requires that an estimate of the measurement uncertainties associated with the emissions test results be included in the report. The measurement uncertainties given below are based on a 95% confidence level (based on a coverage factor (k=2) Measurement Uncertainty Test Item Uncertainty AC power-line conducted emissions ±2.26 dB Emission bandwidth, 6dB bandwidth ±1.42 % RF output power, conducted ±0.
FCC Test Report Report No. : FR442525 2 Test Configuration of EUT 2.1 The Worst Case Modulation Configuration Worst Modulation Used for Conformance Testing Modulation Mode Transmit Chains (NTX) Data Rate / MCS Worst Data Rate / MCS 11b,1-11Mbps 1 1-11 Mbps 1 Mbps 11g,6-54Mbps 1 6-54 Mbps 6 Mbps HT20,M0-15 2 MCS 0-15 M0 HT40,M0-15 2 MCS 0-15 M0 2.2 The Worst Case Power Setting Parameter The Worst Case Power Setting Parameter (2400-2483.5MHz band) RTL819x 2.
FCC Test Report 2.3 Report No.
FCC Test Report 2.4 Report No. : FR442525 Test Setup Diagram Test Setup Diagram – AC Line Conducted Emission Test AC Main 120 Vac / 60 Hz Adapter RJ45 Notebook EUT with power box SPORTON INTERNATIONAL INC. Page No. : 11 of 57 TEL : 886-3-327-3456 Report Version : Rev.
FCC Test Report Report No. : FR442525 Test Setup Diagram - Radiated Test (Below 1GHz) AC Main 120 Vac / 60 Hz Adapter RJ45 Notebook EUT with power box Test Setup Diagram - Radiated Test (Above 1GHz) 120 Vac / 60 Hz Adapter AC Main RJ45 Notebook EUT with power box SPORTON INTERNATIONAL INC. Page No. : 12 of 57 TEL : 886-3-327-3456 Report Version : Rev.
FCC Test Report Report No. : FR442525 3 Transmitter Test Result 3.1 AC Power-line Conducted Emissions 3.1.1 AC Power-line Conducted Emissions Limit AC Power-line Conducted Emissions Limit Frequency Emission (MHz) Quasi-Peak Average 0.15-0.5 66 - 56 * 56 - 46 * 0.5-5 56 46 5-30 60 50 Note 1: * Decreases with the logarithm of the frequency. 3.1.2 Measuring Instruments Refer a test equipment and calibration data table in this test report. 3.1.
FCC Test Report 3.1.5 Report No. : FR442525 Test Result of AC Power-line Conducted Emissions AC Power-line Conducted Emissions Result Operating Mode 1 Operating Function AC Power & Radio link Neutral Power Phase Note 1: “>20dB” means emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found emissions (No emissions were detected.) SPORTON INTERNATIONAL INC. Page No. : 14 of 57 TEL : 886-3-327-3456 Report Version : Rev.
FCC Test Report Report No. : FR442525 AC Power-line Conducted Emissions Result Operating Mode 1 Operating Function AC Power & Radio link Line Power Phase Note 1: “>20dB” means emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found emissions (No emissions were detected.) SPORTON INTERNATIONAL INC. Page No. : 15 of 57 TEL : 886-3-327-3456 Report Version : Rev.
FCC Test Report 3.2 6dB Bandwidth 3.2.1 6dB Bandwidth Limit Report No. : FR442525 6dB Bandwidth Limit Systems using digital modulation techniques: 6 dB bandwidth ≥ 500 kHz. 3.2.2 Measuring Instruments Refer a test equipment and calibration data table in this test report. 3.2.3 Test Procedures Test Method For the emission bandwidth shall be measured using one of the options below: Refer as FCC KDB 558074, clause 8.1 Option 1 for 6 dB bandwidth measurement. Refer as FCC KDB 558074, clause 8.
FCC Test Report 3.2.5 Report No. : FR442525 Test Result of Emission Bandwidth Emission Bandwidth Result Condition Emission Bandwidth (MHz) 99% Bandwidth 6dB Bandwidth Modulation Mode NTX Freq. (MHz) Chain Port 1 Chain Port 2 Chain Port 1 Chain Port 2 11b 1 2412 14.84 - 10.05 - 11b 1 2437 16.76 - 10.06 - 11b 1 2462 15.08 - 10.08 - 11g 1 2412 16.50 - 16.57 - 11g 1 2437 17.69 - 16.54 - 11g 1 2462 16.44 - 16.30 - HT20 2 2412 17.63 17.61 17.68 17.
FCC Test Report 3.3 RF Output Power 3.3.1 RF Output Power Limit Report No. : FR442525 RF Output Power Limit Maximum Peak Conducted Output Power or Maximum Conducted Output Power Limit 2400-2483.
FCC Test Report 3.3.3 Report No. : FR442525 Test Procedures Test Method Maximum Peak Conducted Output Power Refer as FCC KDB 558074, clause 9.1.1 (RBW ≥ EBW method). Refer as FCC KDB 558074, clause 9.1.2 (peak power meter for VBW ≥ DTS BW). Maximum Conducted Output Power [duty cycle ≥ 98% or external video / power trigger] Refer as FCC KDB 558074, clause 9.2.2.2 Method AVGSA-1 (spectral trace averaging). Refer as FCC KDB 558074, clause 9.2.2.3 Method AVGSA-1 Alt.
FCC Test Report 3.3.5 Report No. : FR442525 Directional Gain for Power Measurement Directional Gain (DG) Result Transmit Chains No. 1 2 - Maximum GANT (dBi) 2.66 2.76 - Modulation Mode NTX NSS (Min.) (See the Note 4) 11b,1-11Mbps 1 1 2.66 11g,6-54Mbps 1 1 2.66 HT20,M0-15 2 1 2.71 HT40,M0-15 2 1 2.
FCC Test Report 3.3.6 Report No. : FR442525 Test Result of Maximum Peak Conducted Output Power Maximum Peak Conducted Output Power Result Condition RF Output Power (dBm) Modulation Mode NTX Freq. (MHz) Chain Port 1 Chain Port 2 Sum Chain Power Limit DG (dBi) EIRP Power EIRP Limit 11b 1 2412 22.81 - 22.81 30.00 2.66 25.47 36.00 11b 1 2437 28.24 - 28.24 30.00 2.66 30.90 36.00 11b 1 2462 26.68 - 26.68 30.00 2.66 29.34 36.00 11g 1 2412 22.69 - 22.69 30.00 2.
FCC Test Report Report No. : FR442525 2400-2483.5MHz - Worst RF Output Power Plots SPORTON INTERNATIONAL INC. Page No. : 22 of 57 TEL : 886-3-327-3456 Report Version : Rev.
FCC Test Report Report No. : FR442525 3.4 Power Spectral Density 3.4.1 Power Spectral Density Limit Power Spectral Density Limit Power Spectral Density (PSD) ≤ 8 dBm/3kHz 3.4.2 Measuring Instruments Refer a test equipment and calibration data table in this test report. 3.4.3 Test Procedures Test Method Peak power spectral density procedures that the same method as used to determine the conducted output power.
FCC Test Report 3.4.4 Report No. : FR442525 Test Setup Power Spectral Density 3.4.5 Test Result of Power Spectral Density Power Spectral Density Result Condition Power Spectral Density Modulation Mode NTX Freq. (MHz) 11b 1 2412 -7.64 8 11b 1 2437 -1.60 8 11b 1 2462 -3.43 8 11g 1 2412 -10.21 8 11g 1 2437 -6.62 8 11g 1 2462 -7.12 8 HT20 2 2412 -9.76 8 HT20 2 2437 -6.38 8 HT20 2 2462 -9.89 8 HT40 2 2422 -16.51 8 HT40 2 2437 -11.
FCC Test Report 3.5 Transmitter Bandedge Emissions 3.5.1 Transmitter Radiated Bandedge Emissions Limit Report No. : FR442525 Transmitter Radiated Bandedge Emissions Limit 3.5.2 Measuring Instruments Refer a test equipment and calibration data table in this test report. SPORTON INTERNATIONAL INC. Page No. : 25 of 57 TEL : 886-3-327-3456 Report Version : Rev.
FCC Test Report 3.5.3 Report No. : FR442525 Test Procedures Test Method The average emission levels shall be measured in [duty cycle ≥ 98 or duty factor]. Refer as ANSI C63.10, clause 6.9.2.2 bandedge testing shall be performed at the lowest frequency channel and highest frequency channel within the allowed operating band. For the transmitter unwanted emissions shall be measured using following options below: Refer as FCC KDB 558074, clause 11 for unwanted emissions into non-restricted bands.
FCC Test Report 3.5.5 Report No. : FR442525 Transmitter Radiated Bandedge Emissions 2400-2483.5MHz Transmitter Radiated Bandedge Emissions (Non-restricted Band) Modulation NTX Test Freq. (MHz) (dBuV/100kHz) In-band PSD [i] Freq. (MHz) Out-band PSD [o] [i] – [o] (dB) Limit (dB) Pol. (dBuV/100kHz) 11b 1 2412 99.64 2399.94 65.11 34.53 20 V 11b 1 2462 105.55 2543.80 63.80 41.75 20 V 11g 1 2412 94.94 2399.38 66.65 28.29 20 V 11g 1 2462 98.85 2547.10 63.91 34.
FCC Test Report Report No. : FR442525 3.6 Transmitter Unwanted Emissions 3.6.1 Transmitter Radiated Unwanted Emissions Limit Restricted Band Emissions Limit Frequency Range (MHz) Field Strength (uV/m) Field Strength (dBuV/m) Measure Distance (m) 0.009~0.490 2400/F(kHz) 48.5 - 13.8 300 0.490~1.705 24000/F(kHz) 33.8 - 23 30 1.705~30.0 30 29 30 30~88 100 40 3 88~216 150 43.
FCC Test Report 3.6.3 Report No. : FR442525 Test Procedures Test Method Measurements may be performed at a distance other than the limit distance provided they are not performed in the near field and the emissions to be measured can be detected by the measurement equipment.
FCC Test Report 3.6.4 Report No. : FR442525 Test Setup Transmitter Radiated Unwanted Emissions (below 1GHz) Magnetic field tests shall be performed in the frequency range of 9 kHz to 30 MHz using a calibrated loop antenna. Electric field tests shall be performed in the frequency range of 30 MHz to 1000 MHz using a calibrated bi-log antenna.
FCC Test Report 3.6.6 Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Below 1GHz) Transmitter Radiated Unwanted Emissions (Below 1GHz) Operating Mode 1 Operating Function AC Power & Radio link (Transmitter) V Polarization Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Below 1GHz) Operating Mode 1 Operating Function AC Power & Radio link (Transmitter) H Polarization Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.) Note 3: Measurement receive antenna polarization: H (Horizontal), V (Vertical) SPORTON INTERNATIONAL INC. Page No.
FCC Test Report 3.6.7 Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11b Test Freq. (MHz) 2412 NTX 1 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11b Test Freq. (MHz) 2412 NTX 1 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11b Test Freq. (MHz) 2437 NTX 1 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11b Test Freq. (MHz) 2437 NTX 1 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11b Test Freq. (MHz) 2462 NTX 1 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11b Test Freq. (MHz) 2462 NTX 1 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11g Test Freq. (MHz) 2412 NTX 1 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11g Test Freq. (MHz) 2412 NTX 1 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11g Test Freq. (MHz) 2437 NTX 1 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11g Test Freq. (MHz) 2437 NTX 1 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11g Test Freq. (MHz) 2462 NTX 1 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode 11g Test Freq. (MHz) 2462 NTX 1 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT20 Test Freq. (MHz) 2412 NTX 2 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT20 Test Freq. (MHz) 2412 NTX 2 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT20 Test Freq. (MHz) 2437 NTX 2 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT20 Test Freq. (MHz) 2437 NTX 2 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT20 Test Freq. (MHz) 2462 NTX 2 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT20 Test Freq. (MHz) 2462 NTX 2 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT40 Test Freq. (MHz) 2422 NTX 2 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT40 Test Freq. (MHz) 2422 NTX 2 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT40 Test Freq. (MHz) 2437 NTX 2 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT40 Test Freq. (MHz) 2437 NTX 2 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT40 Test Freq. (MHz) 2452 NTX 2 Polarization V Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report Report No. : FR442525 Transmitter Radiated Unwanted Emissions (Above 1GHz) Modulation Mode HT40 Test Freq. (MHz) 2452 NTX 2 Polarization H Note 1: “>20dB” means spurious emission levels that exceed the level of 20 dB below the applicable limit. Note 2: “N/F” means Nothing Found spurious emissions (No spurious emissions were detected.
FCC Test Report 4 Report No. : FR442525 Test Equipment and Calibration Data Instrument Manufacturer Model No. Serial No. Characteristics Calibration Date Remark EMC Receiver R&S ESCS 30 100174 9kHz ~ 2.75GHz Mar. 26, 2014 AC Conduction LISN SCHWARZBECK MESS-ELEKTRONIK NSLK 8127 8127-477 9kHz ~ 30MHz Jan. 21, 2014 AC Conduction EMCO 3810/2NM 9703-1839 9kHz ~ 30MHz Apr. 21, 2014 AC Conduction RF Cable-CON HUBER+SUHNER RG213/U 7.61183201e+012 9kHz ~ 30MHz Oct.