User manual

7. MC Toolkit Maintenance
7.2. MCT202 battery replacement
Revision 12 MC Toolkit User Manual 139
May 2013
7.2 MCT202 battery replacement
Battery Replacement
The battery is not replaceable in the field. For Canada and North America Honeywell Field Solutions Customer
Support contact the number listed in the front of this document.
WARNING !!
Due to certification requirements, all hardware maintenance issues of the MCT202 necessitate that
the unit must be returned to Honeywell for factory servicing.
Battery care: Refer the “Battery Care” section of the “i.roc x20 (-Ex) Pocket PC Safety Instructions Guide” that
is shipped with the MCT202 product
Battery care instructions are also copied here for your convenience. However, always refer to the latest “i.roc x20
(-Ex) Pocket PC Safety Instructions Guide” for your safety.
- The battery should be charged completely before the first use.
- Note that the maximum capacity of the battery is achieved only after about six charging and discharging cycles.
- Since the performance of batteries declines over time, they should be completely discharged occasionally to
maintain their full capacity. When doing this, leave the unit turned on until it turns itself off. Then completely
charge the battery outside the Ex-area.
- Before any longer periods of non-use the battery must be fully charged and recharged regularly (every 3
months).
7.3 SD card replacement
MCT 101 SD Card replacement
SD Card slot is located near the Power button on the PDA
Using Honeywell replacement kit 50020492: Use 34–ST–33–58 (part of the Replacement kit) to replace the SD
Card.
Using Commercial Off The shelf (COTs) SD Card: This is not recommended since MC Toolkit is qualified on
1GB and 2GB SD Cards from SanDisk only. 4GB SDHC Cards are not compatible with 2490 model PDAs.
Should you use COTs part, follow the instructions on the 34-ST-33-59 available on the HPS web site for replacing
and installing the MC Toolkit.
MCT202 SD Card Replacement
The SD card is not replaceable in the field. Call Customer Service numbers listed in the front of this document.