Ex-Handy 06 Safety instructions
Contents 1. 2. 3. 4. 5. 6. 7. 8. 9. 9.1 9.2 9.3 10. 11. 12. 13. 14. 15.
1. Application The Ex-Handy 06 is an explosion-shielded, water-, dust- and impactresistant mobile phone for industrial application in areas with an increased risk of explosion in zones 1, 2, 21 and 22 in accordance with directive 1999/92/EC (ATEX 137) and 94/9/EC (ATEX 95). 2. Safety instructions These safety instructions contain information and safety regulations which are to be observed without fail for safe operation in the described conditions.
- the unit has been subjected to excessive loads. - the unit has been improperly stored. - the unit has been damaged in transit. - unit markings or inscriptions are illegible. - malfunctions occur. - permitted limit values have been exceeded. 4. Safety regulations Use of the explosion-proof mobile phone Ex-Handy 06 assumes that the operator complies with conventional safety regulations and has read the certificate in order to eliminate faulty operation of the unit.
- Observe the corresponding laws that are in force in the respective country regarding the use of mobile phones while operating a vehicle! - Use of the mobile phone in an airplane is not permitted! - Switch off the mobile phone when in close proximity to medical instruments and if you are requested to do so by corresponding regulations! - Manufacturers of cardiac pacemakers recommend a minimum distance of 15.3 cm (6“) is maintained between a mobile phone and a pacemaker.
5. Ex-Data Certificate of Conformity no.: Ex-designation: PTB 10 ATEX 2009 X II 2G Ex ib IIC T4 II 2D Ex ibD 21 T130°C Ex-Handy 06 Approved for zone 1, device group II, explosion group IIC (explosive gases, vapours or mist), temperature class T4. Approved for zone 21, device group II, dust Ex-atmosphere, max. surface temperature (for surfaces on which dust can develop) +130 °C. 6.
. SAR certification When communicating over the wireless network, the mobile phone emits low radio waves known as radio frequency energy or RF. The Specific Absorption Rate or SAR is the unit used to measure the amount of RF energy absorbed by the body while using the phone and is expressed in watts/kilogram. In compliance with the product standards in EN 50360:2001, the allowed limit of SAR averaged for 10g tissue is 2.0 (W/kg).
. Button functions Navigation buttons (up/down/left/right) Volume control Menu button Flashlight disabled for Ex-protection Phonebook/ PTT-function Left selection button Right selection button Accept/Makecall button On/Off/Call end button Press and hold to access the mailbox To activate/ deactivate the loudspeaker during a call. To display the ring type menu in the standby mode. Press and hold to lock/unlock the keypad.
. Rechargeable battery and commissioning 9.1 Changing the battery The battery module Ex-AMH 06 of the Ex-Handy 06 may only be changed outside the Ex-area. Only those battery modules which are approved by the manufacturer for your device type may be used (see Safety regulations under point 4). Other battery modules may not be taken into the Ex-area. 9.2 Commissioning 1) Inserting the SIM: Slide the charcoal colored card holder to the right and carefully lift the SIM card holder.
3) Inserting the battery Insert the battery into the recesses on the lower side of the battery compartment. Then press the battery against the device and turn the screws of the battery clockwise. The screws should only be tightened by hand! The phone should not be connected to the charger if the battery has not been assembled. 4) Charging the phone: The battery supplied with the phone is not fully charged. It is recommended to charge the phone for three hours before using it for the first time.
The use of other chargers or batteries is not permitted. If such items are used, your Ex-protection will expire. Used batteries are to be disposed of properly. If you do not intend using the phone for a prolonged period, you should remove the battery. If the unit is going to be stored for a prolonged period, we recommend checking the battery charge condition at regular intervals in to prevent deep discharge. We strongly advise against connecting your phone to the charger if the battery is not inserted.
High quality lithium-ion batteries are used in your Ex-Handy 06 . These batteries have numerous advantages in everyday use, such as a low weight and high capacity in a nevertheless compact construction. In addition these batteries also exhibit practically no memory effect. However, these batteries are susceptible to a natural ageing process which impairs their functionality.
11. Cleaning, maintenance and storage - Only use a suitable cloth or sponge to clean the unit. Do not use any solvents or abrasive cleaning agents when cleaning. - It is recommended that you have the functionality and accuracy of the unit inspected by the manufacturer every two years. - If the unit is going to be stored for a prolonged period, remove the battery module from the unit and check its charge condition at regular intervals. - Do not exceed the permissible storage temperature range of -20 °C .
Return is free of charge and required by law. Please only dispose of discharged batteries in the designated containers and tape the terminals of lithium batteries. The disposal regulations specified above are also applicable for old devices. All batteries and rechargeable batteries can be recycled. Precious raw materials such as iron, zinc and nickel can therefore be reused.
The aforementioned warranty conditions are the sole and only right of the purchaser to compensation, are exclusively valid and replace all other contract or legal warranty obligations. ecom instruments GmbH assumes no liability for special, direct, indirect, accompanying or consequential damage as well as losses including the loss of data, independent of whether it was caused by violation of the warranty obligation, lawful or unlawful action, action in good faith or any other action.
14.
15.
34
Kommunikation Mobile Computing Portable Handlampen Mess- & Kalibriertechnik Communication Portable Lighting Mobile Computing Measurement & Calibration Copyright© 2010 ecom instruments GmbH. Der Inhalt dieses Dokuments darf ohne vorherige schriftliche Genehmigung durch die ecom instruments GmbH in keiner Form, weder ganz noch teilweise vervielfältigt, weitergegeben, verbreitet oder gespeichert werden. Der Inhalt dieses Dokuments wird so präsentiert, wie er aktuell vorliegt.
