Service manual

DCB, DCFCB and DCFCTB Models
50
Installation
Control and Battery Box Installation
The control and battery box is attached to a length of 5” channel. There are five (5)
pre-drilled holes in the channel:
 (1) 1-1/4” convenient lifting point
 (4) 5/8” mounting holes
The total weight of the control/battery boxes including batteries is approximately
364 lb (165 kg). Therefore, it is imperative that the mounting surface and mounting
method selected can safely sustain the weight of the assembly. In addition, the
mounting method and surface used must be able to withstand external mechanical
stresses that may be applied to the assembly.
Installer Supplied Material List
The following is a general list of material required to install the model
DCB/DCFCB/DCFCTB, 2001-130 siren, and the 2001TRB option. This list varies
depending on mounting methods, length of pole, other options, local electrical codes,
etc. Therefore, use this list as a reference guideline only. Stainless steel hardware is
recommended.
Table 8 Installer Supplied Material List
Material Description
QTY
1. 240 VAC, 1 phase/3 wire, fused disconnect
1 ea.
2. FRN 30, 30 Amp time delay fuse
2 ea.
3. 100 Amp meter socket
(if required)
1 ea.
4. 1‖ meter hub
(overhead service only)
1 ea.
5. 1‖ service entrance
(overhead service only)
1 ea.
6. Fork bolt
(overhead service only)
1 ea.
7. 1/2‖ Liquid-Tight, 90 degree connectors
(2001TRB option primary feed)
2 ea.
8. 1‖ Liquid-Tight 90 degree connector
(2001TRB option secondary feed)
1 ea.
9. 1‖ Liquid-Tight 45 degree connector
(2001TRB option secondary feed)
1 ea.
10. 1/2‖ EMT compression box connector
(disconnect/meter ground)
1 ea.
11. 1‖ heavy wall compression fittings
(rotator cabinet/OH meter)
1 ea.
12. 1/2‖ Liquid-Tight flexible conduit
(2001TRB primary feed)
18‖
13. 1‖ Liquid-Tight flexible conduit
(2001TRB option secondary feed)
7 1/2‖
14. 1/2‖ EMT thin wall conduit
(disconnect/meter ground)
10’
15. 1‖ aluminum rigid
(if applicable in your
area/cabinetry-siren raceway)
50’
16. 1/2‖ nail drive straps
(securing 1/2‖ ground pipe)
4 ea.
17. 1/2‖ jiffy straps
(substitute for nail straps)
4 ea.
18. 1‖ heavy wall 2-hole straps
(1‖ raceway clamping)
15 ea.
19. 1‖ lock rings
(1‖ raceway tightening)
5 ea.
20. 1‖ plastic bushings
2 ea.
21. 1/2‖ plastic bushings
2 ea.
22. 1‖ close nipple
(1‖ raceway/cabinet-siren)
1 ea.
23. 1‖ chase nipple
(1‖ LB-cabinet connection)
1 ea.