Instruction Manual

DYNON AVIONICS
Servo Mounting Instructions – Generic Push-Pull Kit 4
101046-000 Rev E
Wiring Overview
The following diagram provides an overview of the autopilot-specific wiring installation. For the
complete set of wiring and configuration instructions, please see the latest Installation Guide for
your Dynon EFIS product. For a SkyView system please reference the Autopilot Servo
Installation, Configuration, and Calibration chapter of your SkyView System Installation guide.
For EFIS-D10A, EFIS-D100 or FlightDEK-D180 please reference the Autopilot Installation and
Configuration chapter of each respective Installation Guide.
Red
Black
Green
Blue
Yellow
Wht/Grn
Wht/Blu
Servo 1
Wires
Pilot-accessible
Servo Power
Switch/Breaker
Aircraft GND
Red
Black
Green
Blue
Yellow
Wht/Grn
Wht/Blu
Servo 2
Wires
Aircraft GND
Aircraft Power (10-30V)
Pitch and Roll Servos
are wired identically, and can
share wiring for convenience at
any point along the run.
5 kohm
Optional resistor for
detecting broken
disengage lines
Pilot-accessible
Disengage/CWS button
(Normally open, momentary)
Usually mounted to the stick
Power (10-30V)
Ground
SkyView Network 1 A or DSAB A
SkyView Network 1 B or DSAB B
Disengage
SkyView Network Data 2 A *
SkyView Network Data 2 B *
Power (10-30V)
Ground
SkyView Network 1 A or DSAB A
SkyView Network 1 B or DSAB B
Disengage
SkyView Network Data 2 A *
SkyView Network Data 2 B *
Servo Current Draw at 12V
(halve the current values for 24V systems)
SV32
Powered but disengaged: 0.1 amps
Engaged and holding, 100% torque: 0.80 amps
Engaged and moving, 100% torque: 1.33 amps
SV42
Powered but disengaged: 0.1 amps
Engaged and holding, 100% torque: 1.11 amps
Engaged and moving, 100% torque: 2.03 amps
SV52
Powered but disengaged: 0.1 amps
Engaged and holding, 100% torque: 1.52 amps
Engaged and moving, 100% torque: 2.80 amps
Aircraft GND
Use 22 AWG wire for SkyNet
and Disengage signals.
Use appropriate wire gauge for
servo power based on current
consumption and length of wire run
Green
Blue
Twisted Pair
Twisted Pair
Twisted Pair
D10A/D100/D180
D25
CONNECTOR
SKYVIEW
D9
CONNECTOR
N/A
N/A
5
4
4
8
6
1
WHT/BLU
WHT/GRN
BLU
GRN
Wht/Grn
Wht/Blu
*NOT USED FOR D10A/D100/D180