Pest Control Equipment User Manual

Control Panel Interface Installation and User Guide
i
T ABLE OF C ONTENTS
Chapter 1 Control Panel Interface Installation
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Conventions Used In This Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Technical Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
Connecting and Disconnecting Power to the Dyno . . . . . . . . . . . . . . . . . .1-3
Removing the Pit Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4
Removing the Control Panel Interface Cover . . . . . . . . . . . . . . . . . . . . . . .1-6
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-7
Installing the Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-8
Battery Gas Warning Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-9
Blower Mounts, Support Arm, and Junction Box . . . . . . . . . . . . . . . . . . .1-10
Mark and Drill the Blower Mounts and Support Arm Mounting Holes . . .1-10
Installing the Blower Mounting Plate, Support Arm, and Junction Box . . .1-11
Installing the Arms and Monitor Tray . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-12
Installing the High Pressure Blowers . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-13
Routing Cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-14
Routing the Control Panel and Pendant Cables . . . . . . . . . . . . . . . . . . . .1-15
Routing the Blower Cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-19
Routing the Motorized Carriage and Wheel Clamp Cables . . . . . . . . . . . .1-20
Routing the Eddy Current Brake, Battery, and Dyno Power Cables . . . . . .1-23
Routing the Pickup Card and Dyno Electronics Cables . . . . . . . . . . . . . . .1-25
Routing the Air Pump Power, Air Fuel Sensor, and Dyno Electronics
Power Cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-26
Junction Box Cover, Cable Cover, and End Cap . . . . . . . . . . . . . . . . . . .1-27
Testing the Motorized Carriage and Wheel Clamp . . . . . . . . . . . . . . . . .1-29