DWMEIGI MG8710 ELECTRIC FOLDING BIKE DWMEIGI MG8710 ELECTRIC FOLDING BIKE User Manual READ THIS MANUAL CAREFULLY BEFORE USE – FAILURE TO DO SO MAY RESULT IN INJURY, PROPERTY DAMAGE AND MAY VOID WARRANTY. KEEP THIS MANUAL FOR FUTURE REFERENCE. PRODUCTS COVERED BY THIS MANUAL MAY VARY IN APPEARANCE, ASSEMBLY, INCLUSIONS, SPECIFICATIONS, DESCRIPTION AND PACKAGING.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Safety & Warning Riding can be a hazardous activity. Certain conditions may cause the equipment to fail without fault of the manufacturer. The product can and is intended to move, and it is therefore possible to lose control, fall-off and/or get into dangerous situations that no amount of care, instruction or expertise can eliminate.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Never spray your bike directly and don’t get the electrical components wet (the battery connector, motor, controller, cables, handlebar controls, etc) Don’t let children under the age of 10 ride the bike. ONLY use the charger which was provided (never use a charger from a different model). The charger is designed for indoor use only. Keep the charger away from water to avoid short circuit.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Introduction Congratulations on purchasing a DWMEIGI pedal assisted bicycle. We hope you enjoy years of satisfactory and safe riding. Read the manual This manual is provided to help you to get the best performance, comfort, enjoyment and safety from your bicycle. The manual describes specific care and maintenance procedures that help protect your warranty and ensure trouble-free use. Please pay particular attention to the section on battery charging and maintenance.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Operation Before riding, ensure that all required fasteners are tightened to the correct torque and charge the battery prior to use. Always wear a helmet and appropriate safety equipment and always keep both hands on the handlebars and both feet on the pedals whilst riding. Read, understand and follow all safety recommendations before riding. Avoid riding in damp conditions, rain etc as this may affect operation or possibly damage the bicycle electronics. No.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Presentation of LCD Screen 6
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Specifications of LCD Display Rated voltage: 48V Rated working current: 10mA Maximum working current: 30mA Off-state leakage current: <1uA Operating temperature: -20℃~ 60℃ Storae temerature: -30℃~ 70℃ General Operation To switch on the E-bike system and provide the power supply to the controller, hold the On/Off button on the remote for 2 seconds. To switch off the E-bike system, hold the On/Off button for 2s. The E-bike system no longer uses the battery power.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Battery level gauge: When the battery is getting low, you will see it on the LCD display, as the battery indicator empties. When this occurs, turn OFF the power switch and only use the pedals to ride, without the assistance of the motor. You will have to charge the battery when you get to an electrical outlet and will be able to use the electric motor again once the unit is fully charged.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Using Brakes All bicycle models are equipped with a front and rear wheel braking system. Brakes are used to slow the bicycle down. The braking systems may use different mechanics, however, the functionality is the same, and that is to change the energy of the moving bicycle into heat energy ("friction"): For disc brakes, this means pads made from a special friction material pinching against a disc mounted to the centre of the bicycle wheel.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Batteries and Battery Charging Before charging, you must turn the power switch to “OFF” and pull out the key. Keep the charger in a dry and ventilated condition when it’s working. Firstly, connect the output plug of the charger with the socket of the battery case properly, and then insert the input plug into the electrical outlet. The chargers indicator light will turn on, which means it’s charging.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Battery Storage When storing the batteries for a long period of time: Charge the batteries at least every 30 days to avoid capacity loss. Batteries slowly self-discharge when unused over a long period. If the battery cells are left at a critically low charge state, the lifespan and capacity will be permanently reduced. Always disconnect the charger from the mains electrical supply and battery before storing the battery.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Lubrication: For a long service life the following parts of your E-Bike should be regularly lubricated every half year: Front axle Chain Rear axle Freewheel Front fork and other rotation parts. For electrical parts, you do not need to lubricate them because they are lubricated in the factory. If you find anything wrong, please go to a bicycle specialist or contact Fortis.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE For safety, longest possible service life and reliability, maintain the bicycle properly. Use the maintenance schedule below for guidance. It is very important that you check certain systems and components before each and every ride. The proper condition and function of these systems is critical to your safety.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Troubleshooting Malfunction Possible Cause Possible Solution Pedal assistance not working 1. Under-charged battery. 1. Motor electrics or switches damaged / faulty. 4. Low tyre pressure. 3. Derailleur cables sticking / stretched / damaged. 1. Stretched chain. 2. Derailleur / shifter not correctly adjusted. 5. Loose bottom bracket / bearings. 3. Pedal bearings too tight. 1. Chain too tight. 4. Pads / discs dirty. 2. Brakes levers binding. 5. 2.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Motor "clicks" / has reduced power and/or shuts off 1. No power when pedal assistance switched ON 1. 2. 2. 3. 4. Pedal assistance OK, but no display 1. Display OK, but no pedal assistance 1. 2. 2. 3. Bicycle runs at full speed without pedalling 1. 2. Pedal assistance operating 1. intermittently or not as 2. expected 3. Charger shows "full charge" in an unusually short amount of time 1.
DWMEIGI MG8710 ELECTRIC FOLDING BIKE Some experts believe that the incorrect or prolonged use of almost any product may cause serious injury or death. To help reduce your risk of serious injury or death, refer to the information below. Consult all documentation, packaging and product labelling before use. Note that some products feature documentation available online. It is recommended to print and retain the documentation.
12 Month Limited Warranty We warrant against possible manufacturing defects providing the following conditions are satisfied: Product is completely and correctly assembled Product is used under normal condition for its intended purpose Product receives all necessary maintenance and adjustments Product is used for general transportation or recreational use only What is covered by this Limited Warranty; 1 Year Frame only 1 Year Warranty on Motor only 1 Year Warranty on Battery only What is not covered
