Operating instructions

ManualsBrandsDuraflame ManualsHome building and Decor64000

-1-

22” Bio-ethanol Indoor/Outdoor Fireplace

Model # 64000

Distributed by:

Duraame, Inc., Stockton, CA 95201

For questions about Assembly and Operating instructions or Warranty Claims

contact Duraame, Inc. Consumer Affairs

info@duraame.com

1 (866) 552-3015

www.duraame.com/illuma

Patents Pending

WARNING: If the information in this manual is not followed exactly, a re or explosion may

result, causing property damage, personal injury, or loss of life.

Do not store or use gasoline or other ammable vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IN THE EVENT OF AN ALCOHOL SPILL: DO NOT light the burner. Extinguish any

open ame near the spill. Wipe up the spill, and wait several minutes for the residue to evaporate.

WARNING: Improper installation, adjustment, alteration, service, or maintenance can cause injury

or property damage. Refer to this manual for correct installation and operational procedures.

WARNING: This appliance is designed for installation only in a solid-fuel-burning masonry replace,

a UL127 factory-built replace, or in an ANSI Z21.91 ventless rebox, or on a table or cabinet.

There are no other standards for this type of appliance for other installations, thus be very careful

and follow all directions for such installations.

This appliance may be installed in a replace or rebox approved for aftermarket, permanently

located, manufactured (mobile) homes, where not prohibited by local codes.

This appliance is for use only with duraame

illuma-fuel

or types of fuel indicated on the

rating plate. This appliance is not convertible for use with other fuels, nor should you use

illuma-fuel

with any product other than duraame

illuma

replaces.

Save this manual for future reference.

Summary of content (18 pages)

PAGE 1
22” Bio-ethanol Indoor/Outdoor Fireplace Model # 64000 Distributed by: Duraflame, Inc., Stockton, CA 95201 For questions about Assembly and Operating instructions or Warranty Claims contact Duraflame, Inc. Consumer Affairs info@duraflame.com 1 (866) 552-3015 www.duraflame.com/illuma Patents Pending WARNING: If the information in this manual is not followed exactly, a fire or explosion may result, causing property damage, personal injury, or loss of life.
PAGE 2
TABLE OF CONTENTS page I. Safety Information......................................................................... 3 II. Setup............................................................................................. 5 III. Minimum Firebox Dimensions....................................................... 7 IV. Clearances..................................................................................... 7 V. Installing Damper Stop.........................................................
PAGE 3
I. SAFETY INFORMATION IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this appliance. Improper use of this appliance or failure to comply with the safety rules can cause serious injury or death from burns, fire, explosion, or carbon monoxide poisoning. Keep this manual. It should be read by all users of the appliance.
PAGE 4
Due to high temperatures, this appliance should be installed and used only in an approved fireplace or firebox away from flammable objects (curtains, clothing, rugs, furniture, etc.). Flammable objects should not come into contact with the appliance or the flames. Keep them at least three feet away. Never place any objects on the appliance or inside the burner. The appliance becomes very hot when in operation.
PAGE 5
the vapors from these products can create a white powdery residue within the burner box or on adjacent walls or furniture. Do not operate this appliance where flammable liquids or vapors are used or stored, or in a dusty environment. If water has entered the burner reservoir of the appliance, ensure that the water has been emptied from the appliance before use. Water can dilute the duraflame illuma-fuel and affect the performance of the appliance. Do not use the appliance if there is visible damage.
PAGE 6
WARNING: Seal any fresh air vent or ash clean-out doors located on the floor or walls of the fireplace. Failure to do so may result in drafts that could cause sooting. Use a heat-resistant sealant. Do not seal the chimney flue damper.
PAGE 7
III. MINIMUM FIREBOX DIMENSIONS WARNING: Maintain or exceed the minimum clearances. IV. CLEARANCES (Vent-free operation only) Firebox Side Firebox Back 26” 18” at least 12” Figure 2 Minimum Dimensions of Firebox WARNING: Maintain or exceed the minimum clearances. V. INSTALLING DAMPER STOP (Vented operation) For vented operation of this appliance, a damper stop must be installed in the fireplace to prevent full closure of the damper blade.
PAGE 8
3. Check each component for shipping damage. If components are damaged, contact the store where purchased or Duraflame, Inc. 4. a1. If installing this unit in a firebox, check the firebox dimensions to ensure that they are at least equal to the minimum dimensions shown in Figure 2. The minimum clearances that the appliance originally required will be adequate for this installation. You will need the two (2) ¼” x 1 ½” masonry screws and the two hold downs provided for this step.
PAGE 9
Figure 3 Placement of rear glass panel Figure 4 Placement of right glass panel Figure 5 Placement of left glass panel Figure 6 Placement of front glass panel -9-
PAGE 10
VII. INSTALLING THE FUEL CANISTER NOTE: Use only 1 liter duraflame® illuma-fuel® bio-ethanol canisters with this appliance. The canisters are recyclable but NOT refillable. 1. Open the door on the left side of the appliance (see Figure 7). 2. Remove the child resistant screw cap from a canister of illuma-fuel (by pushing down on it and twisting at the same time) to expose the foil seal covering the opening of the canister. DO NOT REMOVE THE FOIL SEAL. 3.
PAGE 11
Figure 7 Door on side open Figure 8 Proper placement of canister Figure 9 How to operate snuffer 4. To extinguish the flames, grasp the snuffer knob, and turn it towards you to move the burner cover forward. The slot must be completely covered to extinguish the flames. This appliance can be relit at any time—even immediately after extinguishing, if desired, using the igniter.
PAGE 12
Figure 10 Check for leaks on the floor of the fireplace under the areas indicated. IX. REFUELING This appliance is designed so that one canister of illuma-fuel® (1 Liter) will provide a continuous supply of fuel to the burner for about two hours and thirty minutes*. To allow for uninterrupted burning beyond this time, the burner has been designed so that a few minutes before the fuel is completely exhausted, the flame will start to shift to the right side of the burner.
PAGE 13
6. If the flame is out by this time, use the igniter to start it again. *NOTE: Burn times will vary depending on conditions such as temperature, draft and how level the surface is. Figure 11 How to remove canister when fire is burning X. ADJUSTING BURN TIME You can extend the burn time and flame height of the fire.
PAGE 14
burner may be very sharp. 5. Make sure that all parts of the appliance are returned to their proper operating positions by following assembly instructions. Ensure the piercer is installed properly (see Figure 12). The top surface of the piercer should be level. If it is higher on the back end or on one side, then turn it around and place it back in place again. 6. Check for leaks by installing a fuel canister into the appliance and letting it sit for five minutes.
PAGE 15
XII. TROUBLESHOOTING Use the following guide to solve any problems you might encounter in operating this appliance. PROBLEM SOLUTION 1. You see fuel on the ground near the appliance. • DO NOT light the burner. Extinguish any open flame near the spill. Wipe up the spill, and wait several minutes for the residue to evaporate. If you see no additional fuel on the ground, you may light the burner. If you see additional fuel on the ground, you might have a leak. DO NOT use this appliance if it leaks fuel.
PAGE 16
XIII.
PAGE 17
WARRANTY INFORMATION KEEP THIS WARRANTY Model:_________________________________ Serial No.:______________________________ Date Purchased:_________________________ Always specify model and serial numbers when communicating with Duraflame, Inc. We reserve the right to amend the specifications of this product at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied.
PAGE 18
Some states do not allow a limitation on how long an implied warranty lasts or an exclusion or limitation of incidental or consequential damages, so the above limitation on implied warranties, or exclusion or limitation on damages may not apply to you. This warranty gives you specific legal rights, and you may also have other rights that vary from state to state. For information about this warranty write to: Attn: Consumer Affairs, Duraflame, Inc., 2894 Monte Diablo Ave., Stockton, CA 95203, www. duraflame.