Operating instructions

ManualsBrandsDuraflame ManualsHeater10HM4124

-1-

Bio-ethanol replace burner and 24” log set

Model # 61020

Distributed by:

Duraame, Inc., Stockton, CA 95201

For questions about Assembly and Operating instructions or Warranty Claims

contact Duraame, Inc. Consumer Affairs

info@duraame.com

1 (866) 552-3015

www.duraame.com/illuma

Patents Pending

Tested to UL 1370 for “unvented bio-ethanol burners” by PFS Corporation

Note: Any reference to Burner or Burners applies to both burners in this entire document.

WARNING: If the information in this manual is not followed exactly, a re or explosion may

result, causing property damage, personal injury, or loss of life.

Do not store or use gasoline or other ammable vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IN THE EVENT OF AN ALCOHOL SPILL: DO NOT light the burner. Extinguish

any open ame near the spill. Wipe up the spill, and wait several minutes for the residue to

evaporate.

WARNING: Improper installation, adjustment, alteration, service, or maintenance can cause

injury or property damage. Refer to this manual for correct installation and operational

procedures.

WARNING: This appliance is for installation only in a solid-fuel-burning masonry replace, a

UL127 factory-built replace, or in an ANSI Z21.91 ventless rebox. It is design certied for

these installations in accordance with UL1370. Exception: Do not install this appliance in a

factory-built replace that includes instructions stating that it has not been tested or should

not be used with unvented gas logs.

This appliance may be installed in a replace or rebox approved for aftermarket, permanently

located, manufactured (mobile) homes, where not prohibited by local codes.

This appliance is for use only with duraame

illuma-fuel

or types of fuel indicated on the

rating plate. This appliance is not convertible for use with other fuels, nor should you use

illuma-fuel

with any product other than duraame

illuma

log sets.

Save this manual for future reference.

Summary of content (19 pages)

PAGE 1
Bio-ethanol fireplace burner and 24” log set Model # 61020 Distributed by: Duraflame, Inc., Stockton, CA 95201 For questions about Assembly and Operating instructions or Warranty Claims contact Duraflame, Inc. Consumer Affairs info@duraflame.com 1 (866) 552-3015 www.duraflame.com/illuma Patents Pending Tested to UL 1370 for “unvented bio-ethanol burners” by PFS Corporation Note: Any reference to Burner or Burners applies to both burners in this entire document.
PAGE 2
TABLE OF CONTENTS page I. Safety Information......................................................................... 3 II. Setup............................................................................................. 5 III. Minimum Firebox Dimensions....................................................... 6 IV. Clearances..................................................................................... 7 V. Installing Damper Stop.........................................................
PAGE 3
I. SAFETY INFORMATION IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this appliance. Improper use of this appliance or failure to comply with the safety rules can cause serious injury or death from burns, fire, explosion, or carbon monoxide poisoning. Keep this manual. It should be read by all users of the appliance.
PAGE 4
This appliance is for decorative purposes only and should not be used as a heater. Do not store the duraflame illuma-fuel canisters near the appliance. Store illuma-fuel tightly closed in its original canister in a dry, cool place, out of direct sunlight and away from heat sources, flammable objects and open fires, and out of the reach of children. If swallowed, seek medical attention immediately. In case of contact with eyes, flush immediately with cool water for 15 minutes and seek medical attention.
PAGE 5
Do not dismantle the burner. Do not insert any other fuel canister into the burner. This appliance must be operated using only authorized accessories and equipment. Do not move the appliance while it is burning. This could cause burning fuel to spill and result in injury or a fire. Do not put anything into the flames of the appliance. This could cause sooting and the creation of harmful combustion products. Do not put your head over the burner while lighting it.
PAGE 6
Sliding Burner Cover Back Log Pin Burner Heat Shield Sparker Fuel Reservoir Tank Tray Back Log Support Burner Sparker Piercer Handle Fuel Tank Bracket Screw-down Hole (Another hole on opposite side) Burner / Base Grate Ignition Button Figure 1 Appliance Overview Install this appliance in compliance with all local building codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code (ANSZ223.
PAGE 7
IV. CLEARANCES (Vent-free operation only) Firebox Side Firebox Back 18” 22” 15” 32” Figure 2 Minimum Dimensions of Firebox WARNING: Maintain or exceed the minimum clearances. V. INSTALLING DAMPER STOP (Vented operation) For vented operation of this appliance, a damper stop must be installed in the fireplace to prevent full closure of the damper blade. The damper stop must be adjusted to provide a minimum flue opening of 29 square inches.
PAGE 8
shown in Figure 2. The minimum clearances that the appliance originally required will be adequate for this installation. You will need the two (2) ¼” x 1 ½” masonry screws provided for this step. Place the burner / base in a solid-fuel-burning masonry fireplace, a UL127 factorybuilt fireplace, or an approved (to ANSI Z21.92) ventless firebox, centered left to right on a level surface.
PAGE 9
Figure 3 Logs Figure 4 Placement of front log Figure 5 Showing space between tray and log inside wall on the left Figure 6 Showing space between tray and log inside wall on the right Figure 7 Placement of rear log Figure 8 Placement of right log -9-
PAGE 10
Figure 9 Placement of left log Figure 10 Placement of front middle log Figure 11 Placement of back middle log Figure 12 All logs properly placed Figure 13 Proper placement of front log with a gap between the back of the tray and the hinge plate -10-
PAGE 11
VII. INSTALLING THE FUEL CANISTER NOTE: Use only 1 liter duraflame® illuma-fuel® bio-ethanol canisters with this appliance. The canisters are recyclable but NOT refillable. 1. Open the door on the top of the front log of the log pile (see Figure 14). 2. Remove the child resistant screw cap from a canister of illuma-fuel (by pushing down on it and twisting at the same time) to expose the foil seal covering the opening of the canister. DO NOT REMOVE THE FOIL SEAL. 3.
PAGE 12
4. To extinguish the flames, grasp the handle of the snuffer device, and slide the cover forward over the burner slot. The slot must be completely covered to extinguish the flames. This appliance can be relit at any time—even immediately after extinguishing, if desired, using the igniter. However, if the fuel is hot or even warm the fuel may not ignite using the sparker because the fuel is evaporating at a higher rate than usual and creates and oxygen free environment around the sparker.
PAGE 13
Figure 18 Check for leaks on the floor of the fireplace under the areas indicated. IX. REFUELING This appliance is designed so that one canister of illuma-fuel® (1 L) will provide a continuous supply of fuel to the burner for about an hour and thirty minutes*. To allow for uninterrupted burning beyond this time, the burner has been designed so that ten minutes before the fuel is completely exhausted, the flame will start to shift to the right burner only and then to the right side of the right burner.
PAGE 14
Figure 19 Area safe to touch log while fire is burning Figure 20 How to remove canister when fire is burning X. ADJUSTING BURN TIME You can extend the burn time and flame height of the fire. Experiment with different settings by slowly moving the snuffer forward as you would when you want to extinguish the flame (see Section IX Step 4), but do not cover the burner completely, or the fire will be extinguished. By moving the snuffer partially over the burner, the burn time will be extended.
PAGE 15
6. Dust the logs gently. 7. Make sure that all parts of the appliance are returned to their proper operating positions by following assembly instructions. Ensure the logs and the piercer are installed properly (see Figure 21). The top surface of the piercer should be level. If it is higher on the left end, then turn it around and place it back in place again. 8. Check for leaks by installing a fuel canister into the appliance and letting it sit for five minutes.
PAGE 16
XII. TROUBLESHOOTING Use the following guide to solve any problems you might encounter in operating this appliance. PROBLEM SOLUTION 1. You see fuel on the ground near the appliance. • DO NOT light the burner. Extinguish any open flame near the spill. Wipe up the spill, and wait several minutes for the residue to evaporate. If you see no additional fuel on the ground, you may light the burner. If you see additional fuel on the ground, you might have a leak. DO NOT use this appliance if it leaks fuel.
PAGE 17
XIII.
PAGE 18
WARRANTY INFORMATION KEEP THIS WARRANTY Model:_________________________________ Serial No.:______________________________ Date Purchased:_________________________ Always specify model and serial numbers when communicating with Duraflame, Inc. We reserve the right to amend the specifications of this product at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied.
PAGE 19
Some states do not allow a limitation on how long an implied warranty lasts or an exclusion or limitation of incidental or consequential damages, so the above limitation on implied warranties, or exclusion or limitation on damages may not apply to you. This warranty gives you specific legal rights, and you may also have other rights that vary from state to state. For information about this warranty write to: Attn: Consumer Affairs, Duraflame, Inc., 2894 Monte Diablo Ave., Stockton, CA 95203, www. duraflame.