MSDS
Page 1 of 2
Date of Preparation: 14-08-18
MATERIAL SAFETY
DATA SHEET
Use in case of an emergency only (613) 996-6666
SECTION I - PRODUCT AND PREPARATION INFORMATION 2W1633
777 McKay Road TRADE NAME:
Flexible Dyna Patch with Tracer
Pickering, Ontario MANUFAC. CODE:
2W1633
L1W 3A3 (905)683-0411 PRODUCT CLASS:
Non Regulated
WHIMIS CLASS:
Non Regulated
SECTION II - HAZARDOUS INGREDIENTS
INGREDIENT CAS NO. % Exposure Limit
Limestone (Calcium Carbonate) 1317-65-3 30-60
10 mg/m3 as Dust (ACGIH TLV)
15 mg/m3 Total Dust (OSHA PEL)
5 mg/m3 Respirable Fraction (OSHA PEL)
Kaolin Clay 1332-58-7 3-7
2 mg/m3 as Respirable Dust (ACGIH TLV)
10 mg/m3 Total Dust (OSHA PEL)
5 mg/m3 Respirable Fraction (OSHA PEL)
Titanium Dioxide 13463-67-7 1-5
10 mg/m3 as Dust (ACGIH TLV)
10 mg/m3 Total Dust (OSHA PEL)
5 mg/m3 Respirable Fraction (OSHA PEL)
Ceramic Microsphere 66402-68-4 10-30
10 mg/m3 as Inhablable Particluate (ACGIH TLV-TWA)
3mg/m3 as Resirable Fraction (ACGIH TLV-TWA)
15 mg/m3 Total Dust (OSHA PEL)
5 mg/m3 Respirable Fraction (OSHA PEL)
Silica, Quartz (naturally occuring component of
Limestone)
14808-60-7 0.5-1.4
0.025 mg/m3 as Dust (ACGIH TLV)
0.1 mg/m3 Respirable Fraction (OSHA PEL)
SECTION III - PHYSICAL DATA
ODOUR AND APPEARANCE ODOUR TRESHOLD PERCENT NON VOLATILE BY WEIGHT EVAPORATION RATE VAPOUR PRESSURE (mmHg)
very low odour; white paste No value available 75 - 77%
slower than n-Butyl Acetate
Not Available
BOILING POINT pH VALUE FREEZING POINT DENSITY (g/ml) VAPOUR DENSITY (Air = 1)
100°C Not Available Not Applicable 1.2 Not Available
VOC STATEMENT (g/L)
23 max.
SECTION IV - FIRE AND EXPLOSION HAZARDS
TDG FLAMMABILITY CLASSIFICATION/ FLASHPOINT HAZARDOUS COMBUSTION PRODUCTS
Non Flammable °C WHEN FORCED TO BURN, BY PRODUCTS MAY INCLUDE BUT NOT LIMITED TO CARBON MONOXIDE CARBON DIOXIDE,
TCC EXTINGUISHING MEDIA
Foam, dry chemical, carbon dioxide or any class B extinguishing agent
UNUSUAL FIRE AND EXPLOSION HAZARDS
SPECIAL FIREFIGHTING PROCEDURES
SECTION V - HEALTH HAZARD DATA: TOXICOLOGICAL PROPERTIES AND FIRST AID MEASURES
ACUTE EFFECTS OF OVEREXPOSURE EMERGENCY AND FIRST AID PROCEDUES
Prepared by: Technical Committee
LD50s and LC50s Route and Species
None
LD50 (oral-rat) > 5000 mg/kg
LD50 (dermal-rat) >5000 mg/kg
LC50(inhl-rat) 6.8 mg/L 4h
LD50 (oral-rat) >10,000 mg/kg
LD50 (dermal-rabbit) >10,000 mg/kg
Not Available
Not Available
INHALATION: Dust of this product may cause irritation of the nose, throat, and respiiratory tract. Contains cystalline silica which is
isted in IARC and NTP as carcinogen and may cause lung damage (SIlicosis) on concentrations exceeding
coccupational exposure limits. Also contains Titanium Dioxide which has IARC Group 2B (possible carcinogen)
rating based on inadequate evidence in humans and sufficient evidence in experimental animals. However,
crystalline silica and titanium dioxide present in this product are encapsulated in the liquid and will only be liberated if
the product is sanded or abraded. Be sure to observe appropriate precautions and wear appropriate personal
protective equipment.
EYE CONTACT: May cause moderate eye irritatiion
SKIN CONTACT: This material may cause defatting and irritation of skin (Dermatitis) upon prolonged or
repeated contact.
INGESTION: Swallowing can cause nausea, vomiting and diarrhea .
INHALATION: Remove victim to fresh air. Restore breathing. Treat symptomatically.
Consult a physician.
SPLASH (EYES): Flush immediately with large amounts of water for at least 15 minutes.
Take to a physician for medical treatment.
SPLASH (SKIN): Wash affected areas with soap and water. Remove contaminated
clothing.
INGESTION: Drink 1 or 2 glasses of water to dilute. DO NOT INDUCE VOMITING.
Consult a physician or Poison Control center immediately. Treat
symptomatically.
Not Applicable
Self-contained breathing apparatus is recommended.