User Manual

2348-065-E-10-11 Page 5
Table of Contents
Section 1 – Introduction
1.1 General Information..................................................................................................................................7
1.2 Visitor Elevator Control
1.2.1 Lobby Hall Up Call On..............................................................................................................8
1.2.2 Lobby Hall Up Call Off..............................................................................................................8
1.3 Resident Elevator Control ........................................................................................................................9
1.3.1 Programming Resident Floor Control Relay Time ...................................................................9
1.4 System Requirements ..............................................................................................................................10
Section 2 –Control Cabinet Installation
General Information..................................................................................................................................................11
2.1 Large Housing ..........................................................................................................................................12
2.2 Small Housing ..........................................................................................................................................13
Section 3 – Set-up Information
3.1 Block Diagram ..........................................................................................................................................15
3.2 Board Set-up ............................................................................................................................................16
3.2.1 Elevator Shaft Identification .....................................................................................................16
3.2.2 Floor Identification....................................................................................................................16
3.2.3 Relay Settings ..........................................................................................................................17
3.2.4 Lobby Hall Up Call Relay .........................................................................................................17
3.3 Switch Settings & Description ..................................................................................................................18
Section 4 – Wiring Information
4.1 General Information..................................................................................................................................19
4.2 Control Board Terminal Identification .......................................................................................................20
4.3 Power Wiring Block Diagram....................................................................................................................22
4.4 Control Wiring
4.4.1 Wiegand Wiring........................................................................................................................23
4.4.2 Floor Control Relay Wiring .......................................................................................................23
4.4.3 Lobby Hall Up Call Relay .........................................................................................................24
4.4.4 Ground Floor Detect Switch .....................................................................................................24
4.4.5 Resident Access Device ..........................................................................................................24
Wiring Diagram.........................................................................................................................................................25
Detail Wiring Diagram...............................................................................................................................................26
Section 5 – Elevator Control
Common Oversights.................................................................................................................................................27
Software Programming.............................................................................................................................................28
Section 6 – Trouble Shooting
6.1 General Trouble Shooting ........................................................................................................................35
6.2 Programming Trouble Shooting Aids
6.2.1 Automatic Test #1 ....................................................................................................................36
6.2.2 Manual Test # 2 .......................................................................................................................36
6.3 Appendix...................................................................................................................................................37
Relay Wiring Identification Sheets............................................................................................................38