Instruction Manual

ManualsBrandsDometic ManualsDometic CFX Portable FridgeWaeco CFX-75DZW Dual Zone Portable Fridge / Freezer, Lithium Battery & Solar Pack

CFX75DZW, CFX95DZW

Compressor Fridge & Freezer

Operating manual

PORTABLE REFRIGERATION

CFX SERIES

CFX75_95DZW--O-AU.book Seite 1 Dienstag, 5. September 2017 2:08 14

Summary of content (32 pages)

PAGE 1
CFX75_95DZW--O-AU.book Seite 1 Dienstag, 5.
PAGE 2
CFX75_95DZW--O-AU.book Seite 2 Dienstag, 5.
PAGE 3
CFX75_95DZW--O-AU.book Seite 3 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW Please read this operating manual carefully before starting the device. Keep it in a safe place for future reference. If the device is passed on to another person, this operating manual must be handed over to the user along with it. The manufacturer cannot be held liable for damage resulting from improper usage or incorrect operation. Contents 1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 4
CFX75_95DZW--O-AU.book Seite 4 Dienstag, 5. September 2017 2:08 14 Explanation of symbols CFX75DZW, CFX95DZW 8 Cleaning and maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27 9 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 10 Guarantee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 11 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 5
CFX75_95DZW--O-AU.book Seite 5 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 2 Safety instructions 2.1 General safety ! WARNING! Safety instructions • Do not operate the cooling device if it is visibly damaged. • If this cooling device's power cable is damaged, it must be replaced by the manufacturer, customer service or a similarly qualified person in order to prevent safety hazards. • This cooling device may only be repaired by qualified personnel.
PAGE 6
CFX75_95DZW--O-AU.book Seite 6 Dienstag, 5. September 2017 2:08 14 Safety instructions CFX75DZW, CFX95DZW • Never pull the plug out of the socket by the cable. • If the cooling device is connected to the DC outlet: Disconnect the cooling device and other power consuming devices from the battery before connecting a quick charging device. • If the cooling device is connected to the DC outlet: Disconnect the cooling device or switch it off when you turn off the engine.
PAGE 7
CFX75_95DZW--O-AU.book Seite 7 Dienstag, 5.
PAGE 8
CFX75_95DZW--O-AU.book Seite 8 Dienstag, 5. September 2017 2:08 14 Accessories 4 CFX75DZW, CFX95DZW Accessories Available as accessory (not included in scope of delivery): Designation Ref. no.
PAGE 9
CFX75_95DZW--O-AU.book Seite 9 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 6 Function description Function description The cooler can chill products, keep them cool as well as freeze them. A low maintenance refrigerant circuit with compressor provides the cooling. The generous insulation and powerful compressor ensure efficient and fast cooling. The cooler has two separate compartments which can be adjusted independently.
PAGE 10
CFX75_95DZW--O-AU.book Seite 10 Dienstag, 5. September 2017 2:08 14 Function description 6.
PAGE 11
CFX75_95DZW--O-AU.book Seite 11 Dienstag, 5.
PAGE 12
CFX75_95DZW--O-AU.book Seite 12 Dienstag, 5.
PAGE 13
CFX75_95DZW--O-AU.book Seite 13 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 7 Operation 7.1 Before initial use I Operation NOTE Before starting your new cooler for the first time, you should clean it inside and outside with a damp cloth for hygienic reasons (please also refer to the chapter “Cleaning and maintenance” on page 27). Reversing the lid opening direction The lid hinges can be moved to the opposite side if you want to open the lids from the opposite direction.
PAGE 14
CFX75_95DZW--O-AU.book Seite 14 Dienstag, 5. September 2017 2:08 14 Operation CFX75DZW, CFX95DZW 6 B A C D ➤ Remove the two plastic covers from the centre hinge (A). ➤ Remove the four screws from the centre hinge (B) and take off the hinge. ➤ Remove the plastic cover from the new centre hinge position with a small screwdriver and re-fit to the old hinge position (C). ➤ Re-fit the centre hinge in the new position. ➤ Insert the lids in the hinges on the opposite side (D).
PAGE 15
CFX75_95DZW--O-AU.book Seite 15 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW Operation Selecting the temperature units Temperature display units can be switched between Celsius and Fahrenheit as follows: ➤ Switch on the cooler. ➤ Press the “SET” button (fig. 3 4, page 10) three times. ➤ Use the “UP +” (fig. 3 10, page 10) or “DOWN –” (fig. 3 9, page 10) buttons to select Celsius or Fahrenheit. ✓ The selected temperature units then appear in both displays for a few seconds.
PAGE 16
CFX75_95DZW--O-AU.book Seite 16 Dienstag, 5. September 2017 2:08 14 Operation 7.3 CFX75DZW, CFX95DZW Connecting the cooler Connecting to a battery (vehicle or boat) The cooler can be operated with 12 Vg or 24 Vg. A NOTICE! Danger of damage! Disconnect the cooler and other consumer units from the battery before you connect the battery to a quick charging device. Overvoltage can damage the electronics of the device.
PAGE 17
CFX75_95DZW--O-AU.book Seite 17 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW Operation Connecting to AC mains (e.g. in the home or office) D DANGER! Danger of electrocution! • Never handle plugs and switches with wet hands or if you are standing on a wet surface. • If you are operating your cooler on board a boat with an AC mains connection, you must install a residual current circuit breaker between the AC mains and the cooler. Seek advice from a trained technician.
PAGE 18
CFX75_95DZW--O-AU.book Seite 18 Dienstag, 5. September 2017 2:08 14 Operation 7.4 CFX75DZW, CFX95DZW Using the battery monitor The device is equipped with a multi-level battery monitor that protects your vehicle battery against excessive discharging when the device is connected to the on-board DC supply. If the cooler is operated when the vehicle ignition is switched off, the cooler switches off automatically as soon as the supply voltage falls below a set level.
PAGE 19
CFX75_95DZW--O-AU.book Seite 19 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 7.5 A Operation Using the cooler NOTICE! Danger of overheating! Ensure at all times that there is sufficient ventilation so that the heat that generated during operation can dissipate. Ensure that the ventilation slots are not covered. Make sure that the device is sufficiently far away from walls and other objects so that the air can circulate. ➤ Place the cooler on a firm foundation.
PAGE 20
CFX75_95DZW--O-AU.book Seite 20 Dienstag, 5. September 2017 2:08 14 Operation CFX75DZW, CFX95DZW Latching the cooler lids ➤ Close the lids. ➤ Press the latches (fig. 2 1, page 10) down, until they latch in place audibly. I 7.6 NOTE – Lid Open Alarm If the lid is left open for three minutes or more and the device is switched on, the interior light will flash until the lid is closed. Setting the temperature ➤ Press the “SET” button (fig.
PAGE 21
CFX75_95DZW--O-AU.book Seite 21 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 7.7 Operation Switching a compartment off or on If only one compartment is required, the other compartment can be switched off to save energy. Switching off compartment If the display of the compartment shows a temperature, you can switch off the compartment as follows: ➤ Press the “SET” button (fig.
PAGE 22
CFX75_95DZW--O-AU.book Seite 22 Dienstag, 5. September 2017 2:08 14 Operation 7.8 CFX75DZW, CFX95DZW Enabling Wi-Fi signal for optional app The cooler can be controlled via Wi-Fi using an app that you can install on a compatible device. The app has control, display and alarm functions. You find further information on the Dometic website for your country (see back page). Note that the app may not be available in your country. The Wi-Fi name of the compressor cooler begins with “CFX”.
PAGE 23
CFX75_95DZW--O-AU.book Seite 23 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 7.9 Operation Set brightness of displays The display brightness can be dimmed for low ambient light conditions. To set the dimming level of the displays proceed as follows: ➤ Switch on the cooler. ➤ Press the “SET” button (fig. 3 4, page 10) five times. ➤ Use the “UP +” (fig. 3 7, page 10) or “DOWN –” (fig. 3 6, page 10) buttons to set the brightness of the displays.
PAGE 24
CFX75_95DZW--O-AU.book Seite 24 Dienstag, 5. September 2017 2:08 14 Operation 7.11 CFX75DZW, CFX95DZW USB port for power supply The USB port allows you to charge small devices like mobile phones and mp3-players. To use your cooling box with any USB devices, simply connect a USB cable (not included) to your device. I NOTE Ensure that any small device connected to the USB port is compatible with 5 V/500 mA operation. 7.12 Switching off the cooler ➤ Empty the cooler. ➤ Switch the cooler off.
PAGE 25
CFX75_95DZW--O-AU.book Seite 25 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW Operation 7.14 Replacing the AC fuse D DANGER! Danger of electrocution! Disconnect the power supply and the connection cable before you replace the device fuse. ➤ Disconnect the power supply to the device. ➤ Pull off the connection cable. ➤ Pry out the fuse insert (fig. 4 2, page 12) with a screwdriver. ➤ Replace the defective glass fuse with a new one that has the same type and rating (4A 250V).
PAGE 26
CFX75_95DZW--O-AU.book Seite 26 Dienstag, 5. September 2017 2:08 14 Operation 7.16 CFX75DZW, CFX95DZW Replacing the light PCB 8 A B C ➤ Disconnect the power supply to the device. ➤ Pry out the transparent cover with a screwdriver (A). ➤ Unscrew the PCB mounting screws (B). ➤ Pull out the plug from the PCB (C). ➤ Replace the defective light PCB with a new one. ➤ Fit the new PCB using reverse of removal instructions. ➤ Press the transparent cover back into the housing.
PAGE 27
CFX75_95DZW--O-AU.book Seite 27 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 8 ! A Cleaning and maintenance Cleaning and maintenance WARNING! Always disconnect the device from the power supply before you clean and service it. NOTICE! Risk of damage • Never clean the cooler under running water or in dish water. • Do not use abrasive cleaning agents or hard objects during cleaning as these can damage the cooler. ➤ Occasionally clean the device interior and exterior with a damp cloth.
PAGE 28
CFX75_95DZW--O-AU.book Seite 28 Dienstag, 5. September 2017 2:08 14 Troubleshooting 9 CFX75DZW, CFX95DZW Troubleshooting Fault Possible cause Suggested remedy Device does not function, LED does not glow. No voltage was detected in the DC power outlet. In most vehicles the ignition must be turned on before power will be supplied to the DC power outlet. No voltage present in the AC voltage outlet. Try using another plug outlet. The device fuse is defective.
PAGE 29
CFX75_95DZW--O-AU.book Seite 29 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW 10 Guarantee Guarantee The statutory warranty period applies. If the product is defective, please contact the manufacturer's branch in your country (see the back of the instruction manual for the addresses) or your retailer.
PAGE 30
CFX75_95DZW--O-AU.book Seite 30 Dienstag, 5. September 2017 2:08 14 Technical data 12 CFX75DZW, CFX95DZW Technical data Ref. no.: Connection voltage: Rated current: Cooling capacity: CFX75DZW CFX95DZW 9600001410 9105306502 12/24 Vg and 100 – 240 Vw 12 Vg: 7.9 A 24 Vg: 3.6 A 100 Vw: 0.93 A 240 Vw: 0.38 A 12 Vg: 9.2 A 24 Vg: 4.5 A 100 Vw: 1.10 A 240 Vw: 0.
PAGE 31
CFX75_95DZW--O-AU.book Seite 31 Dienstag, 5. September 2017 2:08 14 CFX75DZW, CFX95DZW Dimensions (W x H x D) in mm Including handles: Without handles: Technical data CFX75DZW CFX95DZW 887 x 472 x 495 832 x 472 x 495 957 x 472 x 530 900 x 472 x 530 31 kg 32 kg Weight: Test/certificates: 4 I NOTE If the ambient temperature is above +32 °C (+90 °F), the minimum temperature cannot be attained.
PAGE 32
CFX75_95DZW--O-AU.book Seite 32 Dienstag, 5. September 2017 2:08 14 BENELUX Dometic Branch Office Belgium Zincstraat 3 B-1500 Halle  +32 2 3598040  +32 2 3598050 Mail: info@dometic.be BRAZIL Dometic DO Brasil LTDA Avenida Paulista 1754, conj. 111 SP 01310-920 Sao Paulo  +55 11 3251 3352  +55 11 3251 3362 Mail: info@dometic.com.br DENMARK Dometic Denmark A/S Nordensvej 15, Taulov DK-7000 Fredericia  +45 75585966  +45 75586307 Mail: info@dometic.