Dometic8700_IOM_APAC(en).book Seite 1 Dienstag, 10.
Dometic8700_IOM_APAC(en).book Seite 2 Dienstag, 10. März 2020 4:45 16 © 2020 Dometic Group. The visual appearance of the contents of this manual is protected by copyright and design law. The underlying technical design and the products contained herein may be protected by design, patent or be patent pending. The trademarks mentioned in this manual belong to Dometic Sweden AB. All rights are reserved.
Dometic8700_IOM_APAC(en).book Seite 3 Dienstag, 10. März 2020 4:45 16 Dometic8700 Please read this instruction manual carefully before installation and first use, and store it in a safe place. If you pass on the product to another person, hand over this instruction manual along with it. Table of contents 1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 2 Important safety instructions for installation. . . . . . . . . . . . . . . . . . . . .
Dometic8700_IOM_APAC(en).book Seite 4 Dienstag, 10. März 2020 4:45 16 Explanation of symbols 1 ! ! A I 2 Dometic8700 Explanation of symbols WARNING! Safety instruction: Indicates a hazardous situation that, if not avoided, could result in death or serious injury. CAUTION! Safety instruction: Indicates a hazardous situation that, if not avoided, could result in minor or moderate injury. NOTICE! Indicates a situation that, if not avoided, can result in property damage.
Dometic8700_IOM_APAC(en).book Seite 5 Dienstag, 10. März 2020 4:45 16 Dometic8700 3 Scope of delivery Scope of delivery The sail trackis not supplied by Dometic and must be purchased separately and installed prior to the installtion of the awning and hardware. Fabric roller tube assembly (must be ordered separately) 1 1 No. in fig.
Dometic8700_IOM_APAC(en).book Seite 6 Dienstag, 10. März 2020 4:45 16 Intended use 4 Dometic8700 No. in fig. 2 Quantity 2 2 Hardware assemblies 3 1 Door Roller Kit 4 2 Bottom mounting bracket 5 1 Pull rod 6 1 set – 1 Description Fixing materials Installation and Operating Manual Intended use The intended use of the awning is to provide shade. The awning is to be used whilst the vehicle is stationary only.
Dometic8700_IOM_APAC(en).book Seite 7 Dienstag, 10. März 2020 4:45 16 Dometic8700 Installing the awning 6 Installing the awning 6.1 Notes on the installation ! WARNING! Failure to obey these warnings could result in death or serious injury. Fire hazard/Electrocution hazard • Make sure there are no obstacles (wires, pipes, etc.) on the RV‘s roof and inside the RV‘s walls. • Shut off gas supply to the RV.
Dometic8700_IOM_APAC(en).book Seite 8 Dienstag, 10. März 2020 4:45 16 Installing the awning A Dometic8700 NOTICE! Damage hazard • Ensure that the awning rail is parallel to the RV floor, and is not warped or curved before installing awning fabric. If the awning rail is not straight, the awning fabric may wrinkle or stretch. • Install back channels on a flat surface, level, and keep parallel with each other to ensure correct function and appearance.
Dometic8700_IOM_APAC(en).book Seite 9 Dienstag, 10. März 2020 4:45 16 Dometic8700 Installing the awning NOTICE 6.2 Installing the awning ➤ Proceed as shown to install the awning (fig. 3, page 10 to fig. e, page 17). I EN NOTE • The awning length is set to suit the Dometic 8300 awning length. • Adjust the RH top casting to outer hole (fig. 3, page 10) to fit the Dometic 8500 awning length. • The LH top casting does not require adjustment.
Dometic8700_IOM_APAC(en).book Seite 10 Dienstag, 10. März 2020 4:45 16 Installing the awning Dometic8700 3 2. 3. 25 m m 6. 4. 1. 5. 4 3. 1. 2.
Dometic8700_IOM_APAC(en).book Seite 11 Dienstag, 10. März 2020 4:45 16 Dometic8700 Installing the awning 5 1. X X 2. 4. 3. I EN 4x 5. Ø 6 4x 6. NOTE Unfurling the awning fabric by one revolution will allow enough space between the RV wall and the awning hardware to guide the fabric into the awning rail.
Dometic8700_IOM_APAC(en).book Seite 12 Dienstag, 10. März 2020 4:45 16 Installing the awning Dometic8700 6 1x 2. 1. 3 7 1. 2. CLICK 3. 12 4. 5.
Dometic8700_IOM_APAC(en).book Seite 13 Dienstag, 10. März 2020 4:45 16 Dometic8700 Installing the awning 8 2x 1. 2x 2. 2x 3. Installing the door roller kit A 9 NOTICE! Damage hazard If a squared corner entry door may contact the awning fabric, the door roller kit must be installed.
Dometic8700_IOM_APAC(en).book Seite 14 Dienstag, 10. März 2020 4:45 16 Installing the awning Dometic8700 Choosing the mounting position for top mounting brackets (fig.
Dometic8700_IOM_APAC(en).book Seite 15 Dienstag, 10. März 2020 4:45 16 Dometic8700 Installing the awning Installing the top mounting brackets a 1. 2. 3. 4x 4x Ø6 4. Releasing the preset tension b 2. 3. 1.
Dometic8700_IOM_APAC(en).book Seite 16 Dienstag, 10. März 2020 4:45 16 Installing the awning I Dometic8700 NOTE Removing the pin will release the factory preset tension. To facilitate removal, you may need to twist the fabric roller tube (as if unrolling awning) by pulling the bottom of tube toward you while pulling on the pin. c CLICK 1. CLICK 2. d 3. CLICK 4.
Dometic8700_IOM_APAC(en).book Seite 17 Dienstag, 10. März 2020 4:45 16 Dometic8700 Installing the awning Securing the awning fabric to the awning rail e 3. 1. 50 mm 50 mm 2. CLICK Verifying the installation ➤ Verify the installation by operating the awning according to verify all parts are functioning correctly (chapter “Using the awning” on page 18). Open and close the awning four or five times to allow for natural self adjustment of the awning fabric.
Dometic8700_IOM_APAC(en).book Seite 18 Dienstag, 10. März 2020 4:45 16 Using the awning Using the awning NOTE 7 Dometic8700 A B You can use the awning in opening position A or B. Opening the awning NOTICE 7.
Dometic8700_IOM_APAC(en).book Seite 19 Dienstag, 10. März 2020 4:45 16 Dometic8700 A Using the awning NOTICE! Damage hazard • Ensure the awning is extended high enough before opening the entry door. • Ensure the lock lever is not flipped to the “roll-up” position prior to swinging the main arm away from the RV. Failure to do so can cause damage to the lock mechanism. • Whenever heavy or prolonged rain or wind is anticipated, or you will leave the awning unattended, it is best to close the awning.
Dometic8700_IOM_APAC(en).book Seite 20 Dienstag, 10. März 2020 4:45 16 Using the awning Dometic8700 g 1. 2. h 3. CLICK 1. CLICK 2. i 1. 2.
Dometic8700_IOM_APAC(en).book Seite 21 Dienstag, 10. März 2020 4:45 16 Dometic8700 Using the awning Opening the awning to position B (page 18) j 1. 2. CLICK 5. 3. 6. 2x 2x 2x 4.
Dometic8700_IOM_APAC(en).book Seite 22 Dienstag, 10. März 2020 4:45 16 Using the awning Dometic8700 l CLICK 4. 6. 5. 2x CLICK 2. 2x 2x 1. 22 3.
Dometic8700_IOM_APAC(en).book Seite 23 Dienstag, 10. März 2020 4:45 16 Dometic8700 7.2 A Using the awning Closing the awning NOTICE! Damage hazard Ensure that the lock is in the “roll-down” position prior to swinging arms toward vehicle. Failure to do so can cause damage to the lock mechanism. ➤ Proceed as shown to close the awning (fig. m, page 23 to fig. p, page 24). m CLICK n 1. CLICK 3. 2.
Dometic8700_IOM_APAC(en).book Seite 24 Dienstag, 10. März 2020 4:45 16 Using the awning Dometic8700 o 1. 2. p CLICK 1. CLICK 2.
Dometic8700_IOM_APAC(en).book Seite 25 Dienstag, 10. März 2020 4:45 16 Dometic8700 8 A Cleaning and maintenance Cleaning and maintenance NOTICE! Damage hazard • Never clean the awning with a high-pressure washer. • Do not use abrasive cleaning agents or sharp objects during cleaning, as these can damage the product. • Do not use solvents to clean the fabric. ➤ Apply silicone spray lubricant as needed to keep the awning’s moving parts operating smoothly.
Dometic8700_IOM_APAC(en).book Seite 26 Dienstag, 10. März 2020 4:45 16 Warranty 9 Dometic8700 Warranty If the product does not work as it should, please contact your retailer or the manufacturer's branch in your country (see dometic.com/dealer). The warranty applicable to your product is 1 year year(s).
Dometic8700_IOM_APAC(en).book Seite 27 Dienstag, 10. März 2020 4:45 16 YOUR LOCAL SUPPORT YOUR LOCAL SALES OFFICE dometic.com/dealer dometic.com/contact dometicĶ ,*ű0 )"0Ŗ,= "s *+-)"1" )&01 *# *+"1& *+- ,&"0ķ 4%& % *+-/&0" 1%" *+"1& /*2-ķ , " #*2,! &, 1%" -2 )& 9)&,$0 *#ĸ DOMETIC GROUP AB "+3E/,0$ 1 , ĉč ŖĉďĉčČ *), 4"!", 4445103036 YOUR LOCAL DEALER 03/2020 dometic.
