Operating instructions

ManualsBrandsDometic ManualsHeat Pump630025.331

INSTALLATION & OPERATING

INSTRUCTIONS

Important: These Instructions

must stay with unit.

Owner read carefully.

RECORD THIS UNIT INFORMATION FOR

FUTURE REFERENCE:

Model Number

Serial Number

Date Purchased

This manual must be read and un-

derstood before installation, ad-

justment, service, or maintenance

is performed. This unit must be in-

stalled by a qualified service tech-

nician. Modification of this product

can be extremely hazardous and

could result in personal injury or

property damage.

Lire et comprendre ce manuel avant de

procéder à l'installation, à des réglages,

de l'entretien ou des réparations.

L'installation de cet appareil doit être

effectuée par un réparateur qualifié.

Toute modification de cet appareil peut

être extrêmement dangereuse et

entraîner des blessures ou dommages

matériels.

MODEL 630025.331

Roof-Top Heat Pump

used with

3106152.006 Mechanical Air Distribution Box

Model

630025.331

REVISION:

Form No. 3309038.010 9/07

(Replaces 3309038.002)

(French 3309039.018)

LaGrange, IN 46761

USA

SERVICE OFFICE

Dometic Corporation

2320 Industrial Parkway

Elkhart, IN 46516

574-294-2511

CANADA

Dometic Corporation

46 Zatonski, Unit 3

Brantford, ON N3T 5L8

CANADA

519-720-9578

For Service Center

Assistance Call:

800-544-4881

Summary of content (10 pages)

PAGE 1
RECORD THIS UNIT INFORMATION FOR FUTURE REFERENCE: Model Number Serial Number Date Purchased MODEL 630025.331 Roof-Top Heat Pump USA SERVICE OFFICE Dometic Corporation 2320 Industrial Parkway Elkhart, IN 46516 574-294-2511 used with 3106152.
PAGE 2
630025.331 Installation Instructions SAFETY INSTRUCTIONS This manual has safety information and instructions to help users eliminate or reduce the risk of accidents and injuries. GENERAL INFORMATION A. Product features or specifications as described or illustrated are subject to change without notice. B. This Air Conditioner Is Designed For: 1. Installation on a recreational vehicle during the time the vehicle is manufactured. 2. Mounting on the roof of a recreational vehicle. 3.
PAGE 3
13,500 Nominal Capacity (BTU/HR) Cooling 12.4 120 VAC, 60 Hz., 1 PH Compressor Rated Load Amps Electrical Rating 60.0 Compressor Locked Rotor Amps 3.5 Fan Motor Rated Load Amps 10.0 Fan Motor Locked Rotor Amps 335 / 250 SCFM-High Speed Max/Min .012 / 0.65 Total Static Max/Min W.C. 23.5 Refrigerant R-22 (Oz.) SPECIFICATIONS Up To 24' Copper 12AWG Minimum Wire Size* 20 Amp AC Circuit Protection ***User Supplied 99 Installed Weight (Pounds) 3.5 KW / 5.
PAGE 4
630025.331 Installation Instructions b. For two unit installations: Install one Air Conditioner 1/3 and one Air Conditioner 2/3’s from front of RV and centered from side to side. INSTALLATION INSTRUCTIONS A. Precautions FIG. 2 1/2L Improper installation may damage equipment, could endanger life, cause serious injury and/ or property damage. L L 2/3L 1/3L 1. Read Installation and Operating Instructions carefully before attempting to start your air conditioner installation. 2.
PAGE 5
630025.331 Installation Instructions 4" FIG. 4 FIG. 5 4" 7-1/8” 4-1/8” 21-3/8” 14-1/4" x 14-1/4” (±1/8”) OPENING Center Line of Unit REAR OF UNIT 7-1/8” KEEP THESE AREAS FREE OF OBSTRUCTIONS 12" d. If the opening exceeds 14-3/8" x 14-3/8", it will be necessary to re-size the opening to 14-1/4" x 14-1/4" (±1/8"). e. If the opening is less than 14-1/8" x 14-1/8", it must be enlarged. 3. New Opening- (Installation Other Than Vent Opening) a.
PAGE 6
30025.331 Installation Instructions D. Wiring Requirements 1. 4. Place the 3106152.006 Mechanical Air Distribution Box Kit. This box contains mounting hardware for the air conditioner and will be used inside the RV. This completes the outside work. Minor adjustments can be done from the inside of the RV if required. 120 VAC Supply Line Route a copper 12 AWG, with ground, 120 VAC supply line from the time delay fuse or circuit breaker box to the roof opening. a.
PAGE 7
630025.331 Installation Instructions 7. Install ceiling template by sliding lower duct over upper duct. See FIG. 11. FIG. 11 Air Conditioner Return Air Opening G. Wiring The System ! WARNING Slide Lower Air Discharge Duct Over Upper Duct Disconnect 120 volt AC. Failure to follow these instructions could create a shock hazard causing death or severe personal injury. Reach up into the return air opening and pull the remaining wires down. 1. Connection of 120 VAC (refer to FIG. 12) FIG.
PAGE 8
630025.331 Installation Instructions H. Air Distribution Box Installation B. Cooling Operation 1. Remove the two return air grills and filters. 2. Slide the front end of the air box over the shafts of the thermostat and selector switch. See FIG.13. 1. Set the thermostat at the desired temperature level. 2. Select the fan speed that best satisfies your needs: a. HIGH COOL: Selected when maximum cooling and dehumidification required. b. MED COOL: Selected when normal or average cooling required. c.
PAGE 9
630025.331 Installation Instructions 4. Under certain conditions, frost may form on the evaporator coil. If this should occur, inspect the filter and clean if dirty. Make sure air louvers are not obstructed. Air conditioners have a greater tendency to frost when the outside temperature is relatively low. This may be prevented by adjusting the thermostat control knob to a warmer setting (counter clockwise).
PAGE 10
630025.331 Installation Instructions UNIT WIRING DIAGRAM AIR BOX WIRING DIAGRAM FIELD WIRING 115 VAC 60 HZ 1 PH FACTORY WIRING USE COPPER LINE SPLICE CONDUCTORS ONLY GRN/YEL BLK WHT THERMOSTAT BLU 2 1 3 GRY BLU WHT BLK GRY WHT BLU BLK BLU SWITCH ROTARY 1 2 BLU 4 ELEC CONN FROM A/C 5 YEL 6 RED WHT GRY 7 8 9 GRN/YEL 3106220.