Material Safety Data Sheet

MATERIAL SAFETY DATA SHEET
SECTION I
DISTRIBUTOR OR MANUFACTURER: EMERGENCY TELEPHONE NO.
Diversitech Corporation
ADDRESS (Number, Street, City, State and ZIP Code)
2530 Lantrac Court Decatur, Georgia 30035
CHEMICAL FAMILY: PRODUCT NAME AND SYNONYMS
Acrylic Emulsion
PRODUCT USE FORMULA
Duct Sealant / Mastic
SECTION II - HAZARDOUS INGREDIENTS
HAZARDOUS CAS PEL (ppm) SKIN LD50 OF INGREDIENT LD50 OF INGREDIENT
INGREDIENTS NUMBER %
TWA STEL CEILING
DESIGNATION (SPECIFY SPECIES AND ROUTE) (SPECIFY SPECIES)
< 1.4
< 0.6
< 2.3
PHYSICAL STATE ODOR AND APPEARANCE VOC (grams/liter) Less Water & Exempt Solvents ODOR THRESHOLD (ppm)
VAPOR PRESSURE VAPOR DENSITY EVAPORATION RATE BOILING POINT (°C) FREEZING POINT
pH SPECIFIC GRAVITY COEFF. WATER/OIL DIST. SOLUBILITY IN WATER VOLATILES BY WT. (%)
SECTION IV - FIRE AND EXPLOSION DATA
FLAMMABILITY
IF YES UNDER
NO
X
WHICH CONDITIONS?
FLASHPOINT (°C) AND METHOD AUTOIGNITION TEMPERATURE (°C) LOWER FLAMMABLE LIMIT (% BY VOLUME) UPPER FLAMMABLE LIMIT (%BY VOLUME)
HAZARDOUS COMBUSTION PRODUCTS
EXPLOSION DATA SENSITIVITY TO IMPACT SENSITIVITY TO STATIC DISCHARGE
N/A
NFPA CODE (REPRESENTATIVE OF THE MOST VOLATILE COMPONENTS IN THESYSTEM)
EXTINGUISHING MEDIA
SPECIAL FIRE FIGHTING PROCEDURES
UNUSUAL FIRE AND EXPLOSION HAZARDS
0.05
mg/m3
Methyl Alcohol
Ammonium Hydroxide
1336-21-6
67-56-1
50 ppm
N/A
Yes
14808-60-7
*This product is not expected to produce any
unusual hazards during normal use. Exposure to
high dust levels may irritate the skin, eyes, nose,
throat, or upper respiratory tract. This product
does not present an inhalation, ingestion, or
contact health hazard unless subjected to
operations such as sawing, sanding or
machining which result in the generation of
airborne particulate. This product contains
quartz (crystalline silica) as a naturally occurring
contaminant.
25 ppm
10
mg/m3
Crystalline silica (impurity)*
Not sensitive to static discharge
Less than 1
Not available
100° C
N/A
Soluble
Not sensitive to impact
Not applicable
Not established
None
Wear a self-contained breathing apparatus with a full face piece (MSHA-NIOSH Approval) with a
pressure demand or other positive pressure mode when fighting fires.
None needed in liquid state. In dry state use water, foam, carbon dioxide, or dry chemical
Health - 1 Flammability -0 Reactivity - 0 Protection -1
8.0 - 9.5
N/A
N/A
Not established
Not established
1.3 - 1.5
SECTION III - PHYSICAL DATA
Paste
White or gray with slight ammonia odor
< 37
[phone]
0° C
N/A
Oral [Rat] 350 mg/kg
29.8 +/- 2%
Not applicable
Proprietary
None
CHEMTREC
50 ppm
250
ppm
50 ppm
Yes
Oral [Rat] 5628mg/kg
Dermal [Rabbit]
15840 mg/kg
Pro-Air Duct Sealant - 800-008, 800-009