6W & 28W Solar Rechargeable Floodlights with PIR Model No: DIO-FL16W-WM-SP DIO-FL28W-WM-SP
CONTENTS SET UP GUIDE ........................................................................................... 3-5 Fixing to a Wall .................................................................................. 5 Fixing to a 50mm Pipe ....................................................................... 5 Precautions. .................................................................................................6 Tools required for Installation ....................................................
SET UP GUIDE NOTE: Theunit will not operate correctlyunlessit is fully charged.When charging the Diodor LED Solar Floodlight, the chargeLEDshouldflash RED. If LED is flashing orange, this indicates a battery fault or the battery may not be connecetd correctly. Remove the battery, clean the contactswith a non-metalliccloth and carefullyslidethebattery backon. 1) Unpackand checkthe contentsin the box, andcheckto makesureyou havethecorrecttools for installaiton. (Seepage9-10for kit contents).
9) Fix the battery waterproof protection cover in place with the four screws provided. 10) Install the Diodor LED Solar Floodlight fitting on to the bracket using the knurled bolts provided. Position the light fitting for optimum PIR coverage (See Fig. 1) 11) Plug the solar panel cable and the light fitting together. 12) Installation is now complete. To test that the unit is working satisfactorily, cover up the solar panel and you will be able to walk test the unit in daylight.
Fixing to a wall 1) Mark off the position using the bracket as a guide. 2) Drill two fixing holes for each bracket, taking into account the length of cable from the solar panel and light fitting. 3) Secure the brackets to the wall. 4) Mount the solar panel onto its fixing bracket (which should be above the light fitting), and set it to the appropriate angle and tighten. 5) Plug the solar panel into the socket on the light fitting.
Precautions Ensure normal safety precautions are taken when using tools and ladders. Install only in dry weather. Please read the Battery Warning (see page 12) before you install. Tools Required for Installation (not sold with the product) • Hammer power drill • Phillips screw drivers • Ladder • No.
BATTERY CONDITION LEDs A) Charge Level: indicators for the battery charge level B) Charging: indicates when the solar panel is charging C) Battery OK: Battery check LED 7
CHOOSING A LOCATION The solar module should be placed outside in direct sunlight away from shade (e.g. tree, building etc.) Position it so that it will not get damaged by animals or debris. Mount the light fitting onto a solid wall or pipe 3 - 5m above the ground. Avoid positioning the Diodor Solar floodlight near heat sources such as hot ventilation ducts or air conditioning units which may interfere with its operation.
KIT CONTENTS 1 x Solar Floodlight 1200Lm, 16W - 1 x 12Ah Battery 2300Lm, 28W - 1 x 18Ah Battery 1200Lm, 16W - 1 x 36 Watt Solar Panel 2300Lm, 28W - 1 x 60 Watt Solar Panel 1 x Waterproof Cover & Rubber Ring (for covering the batteries) 1 x Large Bracket for Solar Panel (for mounting the solar panel) 1 x Small Bracket for Light (for mounting the light) 2 x Pipe Mount Brackets (for mounting on poles) 9
KIT CONTENTS: FIXING KIT BAG 2 x Knurled Bolt & Washers & Spring Washer (for light fitting) 2 x Knurled Bolt & Retaining Nuts (M6) (for solar panel) 4 x Nuts & Bolts & Washers - For Pipe and Solar (for assembling both pipe mounts) 4 x Cover Screws - (T8) 2.5*7 (for assembling waterproof box) 4 x Wall Screws - 8*1.
WARNING: KEEP OUT OF REACH OF CHILDREN TROUBLESHOOTING If your solar charged light does not come on at dusk despite observance of all the instructions, please try the following steps: 1) Make sure that the solar light is not being affected by any other light source 2) Ensure the solar light is not positioned in the shade during the day 3) Check that the battery is installed correctly NOTE: The performance of the Diodor Solar floodlight will vary with the time of year.
WARNING: LI-ION BATTERY WARNING Take great care when handling the battery. Lithium-ion cells and battery packs may get hot, explode or ignite and cause serious injury if exposed to extreme conditions. Be sure to follow the safety warnings listed below: • Do not connect the positive terminal and negative terminal of the battery to each other with any metal object (such as wire). • Do not carry or store battery together with necklaces, hairpins or other metal objects.
• Do not place the battery in microwave ovens, high-pressure containers or on induction cookware. • In the event the battery leaks and the fluid gets into your eye, do not rub the eye. Rinse well with water and immediately seek medical care. If left untreated, the battery fluid could cause damage to the eye.
MANUFACTURER’S WARRANTY This Diodor product is guaranteed for a period of 2 (Two) years from date of purchase, provided the product has been installed in accordance with this instruction manual and local electrical wiring regulations and codes of practice. This guarantee shall become invalid if this product has been incorrectly installed, misused, tampered with or accidentally damaged.
