User's Manual

DIGITAL CONTROL INCORPORATED
lvi DigiTrak F5 Operator’s Manual
LEDs and
Audible Signals
Charger or Battery
Pack Status
Status Description
Action
Flashing Orange
No Battery Pack
Detected
No battery pack or unknown
battery type detected.
Insert viable battery pack.
Solid Green & Solid
Orange
Slow Charge / Voltage
Restoration
Battery pack voltage is less
than 11.0 V, or
Battery pack temperature is
above 104° F (40° C).
None. Charger will slowly
restore battery pack to full
voltage.
Flashing Green &
Solid Orange
Minor Charger Fault
Fault detected within charger
temperature sensor circuitry.
Charger is safe to use
temporarily with charge current
limited to less than 1.0 A, but it
should be sent in for repair as
soon as convenient.
Solid Orange &
Solid Red
Fast Charge
Normal operation; charge
duration is approximately
4 hours.
None.
Alternately Flashing
Green & Orange
Full Charge
Battery pack is charged to
100% capacity.
Remove fully charged battery
pack.
Alternately Flashing
Green & Red
Charge Terminated
Over-discharged battery pack
could not be revived within a
reasonable amount of time, or
battery pack is in an over-
charged condition.
Battery pack is damaged or
near the end of its useable life.
If battery pack is fairly new and
in good physical condition,
contact DCI Customer Service.
Otherwise, battery pack is
unrecoverable and should be
properly recycled.
Alternately Flashing
Orange & Red with
Series of Beeps
Battery Pack
Temperature Fault
Battery pack temperature is
above 122° F (50° C), or
battery pack temperature is
below 32° F (0° C).
If battery pack is hot, try to
cool it down; if cold, try to
warm it up. Then recharge
battery pack.
Flashing Red with
Series of Beeps
Permanent Battery
Pack Fault
Battery pack voltage is less
than 5.0 V.
Battery pack is unrecoverable
and should be properly
recycled.
Flashing Green,
Orange & Red with
Series of Beeps
Major Charger Fault
Unrecoverable hardware
failure of charger electronics
detected.
Stop using charger and send it
in for repair immediately;
please contact DCI Customer
Service.
Warnings and Precautions
DCI assumes no liability for problems that occur when you do not follow these warnings and
precautions, as well as the general precautions outlined in
Safety Precautions and Warnings on page vii.
Warning The charger is designed with adequate safeguards to protect you from
shock and other hazards when used as specified within this manual. If
you use the charger in a manner not specified by this document, the
protection provided by the charger may be impaired. Please read this
manual before using the charger.