Operation Manual

C
ontents
4
Caravan - 11-06 - DET-0030-05E
N
7.12.3 Round seating group with round
table . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
7.12.4 Widening the bed into a playing
area (variant 1). . . . . . . . . . . . . . . . . . . 75
7.12.5 Widening the bed into a playing
area (variant 2). . . . . . . . . . . . . . . . . . . 76
7.12.6 Seating group with two single beds . . . 77
8 Gas system. . . . . . . . . . . . . . . . . . . 79
8.1 General . . . . . . . . . . . . . . . . . . . . . . . . 79
8.2 Gas bottles. . . . . . . . . . . . . . . . . . . . . . 80
8.3 Gas consumption. . . . . . . . . . . . . . . . . 81
8.4 Changing gas bottles . . . . . . . . . . . . . . 81
8.5 Gas isolator taps . . . . . . . . . . . . . . . . . 82
8.6 External gas connection . . . . . . . . . . . 82
8.7 Duomatic switching facility. . . . . . . . . . 83
9 Electrical system . . . . . . . . . . . . . 87
9.1 General safety instructions . . . . . . . . . 87
9.2 Terms. . . . . . . . . . . . . . . . . . . . . . . . . . 87
9.3 12 V power supply . . . . . . . . . . . . . . . . 88
9.3.1 Living area battery, general
(Power Pack SE) . . . . . . . . . . . . . . . . . 88
9.3.2 Checking the living area battery
(Power Pack SE) . . . . . . . . . . . . . . . . . 89
9.3.3 Charge the living area battery
(Power Pack SE) . . . . . . . . . . . . . . . . . 90
9.4 Power pack . . . . . . . . . . . . . . . . . . . . . 91
9.5 Transformer/rectifier EBL 109
(Power Pack SE) . . . . . . . . . . . . . . . . . 93
9.5.1 Battery selector switch . . . . . . . . . . . . . 94
9.5.2 Charging the battery . . . . . . . . . . . . . . 94
9.6 Panel LT 109 (Power Pack SE) . . . . . . 94
9.6.1 12 V main switch . . . . . . . . . . . . . . . . . 95
9.6.2 Charging condition of the living area
battery . . . . . . . . . . . . . . . . . . . . . . . . . 95
9.6.3 Filling level of the water tank . . . . . . . . 95
9.7 240 V power supply . . . . . . . . . . . . . . . 96
9.7.1 240 V connection . . . . . . . . . . . . . . . . . 96
9.7.2 Power cable for external 240 V
connection . . . . . . . . . . . . . . . . . . . . . . 96
9.8 Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . 97
9.8.1 12 V fuses . . . . . . . . . . . . . . . . . . . . . . 97
9.8.2 Fuses 240 V. . . . . . . . . . . . . . . . . . . . . 99
9.9 Connection to the towing vehicle . . . . . 99
9.9.1 Connection diagram 12N-12S
connection . . . . . . . . . . . . . . . . . . . . . . 99
9.9.2 Towing vehicle installation . . . . . . . . . 100
10 Appliances . . . . . . . . . . . . . . . . . . 101
10.1 General . . . . . . . . . . . . . . . . . . . . . . . 101
10.2 Heater . . . . . . . . . . . . . . . . . . . . . . . . 102
10.2.1 To heat properly. . . . . . . . . . . . . . . . . 102
10.2.2 Trumatic S hot-air heater . . . . . . . . . . 102
10.2.3 Circulation fan . . . . . . . . . . . . . . . . . . 104
10.2.4 Alde hot-water heater. . . . . . . . . . . . . 106
10.2.5 Ultraheat additional electric
heater . . . . . . . . . . . . . . . . . . . . . . . . .111
10.2.6 Warming unit for waste water
pipes . . . . . . . . . . . . . . . . . . . . . . . . . .111
10.2.7 Electrical floor warming unit . . . . . . . .112
10.2.8 Floor warming unit/warming unit
for waste water tank . . . . . . . . . . . . . .113
10.3 Dometic air conditioning unit . . . . . . .114
10.4 Boiler . . . . . . . . . . . . . . . . . . . . . . . . .115
10.4.1 Models with waste gas vent on
the right-hand side of the vehicle . . . .115
10.4.2 Truma boiler . . . . . . . . . . . . . . . . . . . .116
10.4.3 Alde boiler. . . . . . . . . . . . . . . . . . . . . .117
10.4.4 Reich boiler. . . . . . . . . . . . . . . . . . . . .118
10.4.5 Hot water source . . . . . . . . . . . . . . . .119
10.5 Cooker . . . . . . . . . . . . . . . . . . . . . . . .120
10.5.1 Gas cooker . . . . . . . . . . . . . . . . . . . . .121
10.5.2 Gas oven . . . . . . . . . . . . . . . . . . . . . .122
10.5.3 Gas cooker with gas oven and
gas grill . . . . . . . . . . . . . . . . . . . . . . . .123
10.5.4 Microwave oven . . . . . . . . . . . . . . . . .124
10.5.5 Extractor hood . . . . . . . . . . . . . . . . . .125
10.6 Refrigerator. . . . . . . . . . . . . . . . . . . . .126
10.6.1 Refrigerator ventilation grill. . . . . . . . .126
10.6.2 Operation (Dometic 4 series) . . . . . . .127
10.6.3 Operation (Dometic 7 series) . . . . . . .129
10.6.4 Operation (Thetford without SES) . . .131
10.6.5 Operation (Dometic 7 series
with manual ignition and frame
heater) . . . . . . . . . . . . . . . . . . . . . . . .132
10.6.6 Refrigerator door locking
mechanism . . . . . . . . . . . . . . . . . . . . .134
11 Sanitary fittings. . . . . . . . . . . . . .139
11.1 Water supply, general. . . . . . . . . . . . .139
11.2 External water supply . . . . . . . . . . . . .139
11.3 Waste water tank . . . . . . . . . . . . . . . .140
11.3.1 Waste water tank, mobile . . . . . . . . . .140
11.3.2 Waste water tank, permanently
installed . . . . . . . . . . . . . . . . . . . . . . .141
11.3.3 Waste water tank in the holder
under the vehicle . . . . . . . . . . . . . . . .141
11.3.4 Odour seal . . . . . . . . . . . . . . . . . . . . .142
11.4 Filling the water system . . . . . . . . . . .142
11.5 Emptying the water system . . . . . . . .142
11.6 Toilet compartment. . . . . . . . . . . . . . .143
11.7 Toilet . . . . . . . . . . . . . . . . . . . . . . . . .144
11.7.1 Swivel toilet. . . . . . . . . . . . . . . . . . . . .144
11.7.2 Toilet with fixed seat . . . . . . . . . . . . . .145
11.7.3 Toilet with separate water tank. . . . . .145
11.7.4 Removing the Thetford cassette. . . . .146
11.7.5 Emptying the Thetford cassette . . . . .147
12 Care . . . . . . . . . . . . . . . . . . . . . . . . .149
12.1 External care . . . . . . . . . . . . . . . . . . .149
12.1.1 Washing with a high-pressure
cleaner . . . . . . . . . . . . . . . . . . . . . . . .149