Shelleymatic® by Delfield Milk, Ice Cream and Milk & Ice Cream Dispensers Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Important Warning And Safety Information WARNING Read This Manual Thoroughly Before Operating, Installing, Or Performing Maintenance On The Equipment. WARNING Failure To Follow Instructions In This Manual Can Cause Property Damage, Injury Or Death. WARNING Do Not Store Or Use Gasoline Or Other Flammable Vapors Or Liquids In The Vicinity Of This Or Any Other Appliance.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Contents Receiving and Inspecting Equipment......................................... 3 Serial Number Location.............................................................. 4 Warranty Information.................................................................. 4 Regulatory Certifications............................................................. 4 Specifications...................................................................
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Serial Number Location Serial number tag locations MF/MFSC — on the end above the refrigeration system. N, N6/N10/N14, and SCF — rear of the unit above the louver. NDF — Front right hand corner under the lid. NLFAC — at the rear of the unit by the power cord. Always have the serial number of your unit available when calling for parts or service. A complete list of authorized Delfield parts depots is available at www.delfield.com.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Specifications Model H.P. Loading/Dispensing Weight (lbs) Amps (115V) NEMA Plug BTU Load Evap BTU/ TD BTU Capacity Ref/Charge Self-contained free-standing milk or beverage dispensers N-520 1/4 sliding top lids 327 5.0 5-15P 189 33/31º 1035 134a/16oz N-860 1/4 sliding top lids 392 5.0 5-15P 259 42/28º 1167 134a/16oz N-1200 1/4 sliding top lids 462 5.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Installation Location These units are intended for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents. Units in this product line can weigh as much as 1500 pounds when it is fully stocked. Reinforce the floor as necessary to provide for maximum loading. For the most efficient refrigeration, be sure to provide good air circulation inside and out.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Installation Continued How to adjust self-leveling dispenser Tools Needed: One small flat head screw driver; One Phillips head screw driver. 1. A lways wear safety glasses when adjusting your dispenser. Also, lock brakes on mobile units before beginning. 2. U nload dispenser and remove stainless steel load tray by lifting straight up and set it aside (see figure 1).
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Operation: N, N6/10/14, NDF, NLFAC, MF & MFSC Series N, N6/10/14, NDF, NLFAC and MFSC Series milk dispensers are set at the factory to maintain temperatures between 36°F and 40°F. No further adjustment should be necessary. To begin operation on self-contained models, plug the electrical supply cord into a receptacle with the correct voltage. Remote models will require a connection to a separate refrigeration system.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Maintenance Door Gasket Maintenance Door gaskets require regular cleaning to prevent mold and mildew build up and also to retain the elasticity of the gasket. Gasket cleaning can be done with the use of warm soapy water. Avoid full strength cleaning products on gaskets as this can cause them to become brittle and crack. Never use sharp tools or knives to scrape or clean the gasket.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Wiring Diagrams Model — MFSC L1 N G N G Condensing Unit Pressure Control Models — N, SCF, NSCF, & NDF L1 Condensing Unit On/off Switch Pressure Control Model — NLFAC L1 N Condensing Unit Thermostat 10 Evap. Fans For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts NLFAC8 3516101 Drier, Filter, 1/4ODF 3516172 Blade, fan, evaporator 3516173 Guard, Plastic, Fan, 6” *377-AZ0-0004 Bolt, Lock 3234684 Lock Assembly, Glass Door 031-264-0000 Bracket, Evaporator Fan Motor *359-411-0041 Louver, 13.00 X 25.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts N-520, 860, 1200 & 1530 000-AYP-0031 Lid Assembly, Top Sliding, N10 *265-774-0039 Carrier, elevator 000-AYP-0032 Lid Assembly, Top Sliding, N14 AE540AT-238-J7 Compressor, Tecumseh 3234105 Locknut/Washer, 1” Drain 3526674 Condensing Unit, 1/4HP, Hi, R134A *359-AZD-0000 Louver, 13.5 x 9 2183348 Cord, power, 16/3 W/Nema 5-15P *359-AZD-0001 Louver, 13.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts NDF-18 SCF-32 6230170 Bumper, Corner, Small, PVC 372-395-0000 Carrier, Large Ice Cream 3234180 Caster, 4, Plate, Swivel, Break **000-BN5-0030 Condensing Unit 3234307 Catch, Door 2193927 Control, Pressure, Low AE630AT-602-J7 Compressor 2183348 Cord, power, 16/3 W/Nema 5-15P 3526675 Condensing Unit, 1/3HP, Hi *030-392-0000 Divider, Shelley IC Tank 2193927 Control, Pressure, Low 3234242 Dra
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts MFSC-31, MFSC-44, MFSC-57, MFSC-2821 MF-2020 372-395-0000 Carrier, ice cream 372-395-0038 Carrier AE540AT-238-J7 Compressor, Tecumsh 1701278 Cover, expansion valve 3526674 Condensing Unit, 1/4HP, Hi, R134A *030-392-0000 Divider, Shelley IC Tank 2193927 Control, Pressure, Low 3234242 Drain, Plastic, 1IPS, 2.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts - Condensing Units 2 2 3 3 4 1 4 5 1 5 6 6 8 7 9 8 10 Condensing Unit Condensing Unit Key Part Number Description Key Part Number Description - 000-BN5-0030 Condensing Unit - 000-BN5-003G Condensing Unit 1 2160028 Fan, Axial, 5.5”, 120V 1 2160028 Fan, Axial, 5.5”, 120V 2 2160030 Guard, Fan, 6.0” 2 2160030 Guard, Fan, 6.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts - Elevator Assemblies 6 5 1 4 3 1 2 7 2 6 3 5 4 Elevator Assembly Elevator Assembly Key Part Number Description - 000-546-003E Elevator Assembly, Large - 000-546-0035 Elevator assembly, 22.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Part Prints 3516265 - Valve, EPR, 3/8 ODF 000-BI7-0033 - Cover assembly, NLFAC8 000-BI7-0034 - Cover Assembly, Lift, NLFAC-12 000-BI7-0035 - Cover Assembly, Lift, NLFAC-16 359-AZD-0000 - Louver, 13.5” x 9” 359-AZD-0001 - Louver, 13.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Standard Labor Guidelines To Repair Or Replace Parts On Delfield Equipment Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage. • • • • A maximum of 1-hour is allowed to diagnose a defective component. A maximum of 1-hour is allowed for retrieval of parts not in stock. A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Notes For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.
Covington, TN Mt. Pleasant, MI Thank you for choosing Delfield! Help is a phone call away. Help our team of professional, courteous customer service reps by having your model number and serial number available at the time of your call (800) 733-8829. Model:________________________ S/N: _______________________ Installation Date:________________ For a list of Delfield’s authorized parts depots, visit our website at www.delfield.com Register your Delfield warranty online. Go to www.delfield.
