Installation manual

Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual
17
For customer service, call [phone], [phone], Fax [phone], www.delfield.com
Standard Labor Guidelines To Repair Or Replace Parts On Delfield Equipment
Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage.
A maximum of 1-hour is allowed to diagnose a defective component.
A maximum of 1-hour is allowed for retrieval of parts not in stock.
A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed.
Overtime, installation/start-up, normal control adjustments, general maintenance, glass breakage, freight damage, and/or
correcting and end-user installation error will not be reimbursed under warranty unless pre-approved with a Service Work
Authorization from Delfield. You must submit the number with the service claim.
Labor Of 1 Hour Is Allowed To Replace:
Compressor Start Components and Overload Protector
Condensate Element
Defrost Timer
Door Hinges, Locks, and Gaskets
Evaporator/Condenser Fan Motor and Blade
Fan Delay/Defrost Termination Switch
Hi-limit/Thermal Protector Switch
Springs/Lowerator
Thermometer
Thermostat
Labor Of 2 Hours To Replace:
Defrost Element
Locate/Repair Leak
Pressure Control
Labor Of 3 Hours To Replace:
Condenser or Evaporator Coil
Expansion Valve
Labor Of 4 Hours To Replace:
Compressor
This includes recovery of refrigerant and leak check.
$55.00 maximum reimbursement for refrigerant recovery (includes recovery machine, pump, torch, oil, flux, minor fittings,
solder, brazing rod, nitrogen, or similar fees.)
Refrigerants:
R134A A maximum of $5.00/lb. or 31¢/oz. will be reimbursed.
R404A A maximum of $15.00/lb. or $1.00/oz. will be reimbursed.
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•