Installation manual

International F5 & F15 Series Service and Installation Manual
19
For customer service, call [phone], [phone], Fax [phone], www.deleld.com
Standard Labor Guidelines To Repair Or Replace Parts On Delfield Equipment
Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage.
• A maximum of 1-hour is allowed to diagnose a defective component.
• A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed. Actual travel to be charged.
• Overtime, installation/start-up, normal control adjustments, general maintenance, glass breakage, freight damage, and/or correcting and
end-user installation error will not be reimbursed under warranty unless pre-approved with a Service Work Authorization from Delfield.
You must submit the number with the service claim.
• Actual repair time will be paid at or below guidline.
• Parts on the critcal stock list must be air freighted at the expense of the service agent.
Labor Up To 1-Hour Is Allowed To Replace
• Infinite Switch • Contactor/Relay
• Door Jamb Switch • Transformer
• Solenoid Coil • Evaporator/Condenser Fan Motor and Blade
• Hi-limit/Thermal Protector Switch • Circulating Fan Motor and Blade
• Fan Delay/Defrost Termination Switch • Digital Control
• Compressor Start Components and Overload Protector • Water Level Sensor/Probe
• Defrost Timer • Door Hinges, Locks, and Gaskets
• Thermostat • Condensate Element
• Thermometer • Springs/Lowerator
• Gear Motor
Labor Up To 2 Hours To Replace
• Drawer Tracks/Cartridges • Defrost Element
• Pressure Control • Heating Element
• Solenoid Valve • Locate/Repair Leak
Labor Up To3 Hours To Replace
• EPR or CPR Valve • Condenser or Evaporator Coil
• Expansion Valve • Cap Tube
Labor Up To 4 Hours To Replace
• Compressor
- This includes recovery of refrigerant and leak check.
- $55.00 maximum reimbursement for refrigerant recovery (includes recovery machine, pump, torch, oil, flux, minor fittings, solder,
brazing rod, nitrogen, or similar fees).
Refrigerants
• R22 A maximum of $4.00/lb. or 25¢/oz. will be reimbursed.
• R134A A maximum of $7.00/lb. or 44¢/oz. will be reimbursed.
• R404A A maximum of $16.00/lb. or $1.00/oz. will be reimbursed.