Owner`s manual

29
30SB,36SB,45SB

Rev Nov2014
Snow BEAST
Troubleshoong
Problem Possible Causes Soluon
Enginewillnotstart 1. KeyintheOFFposion
2. Insufficientfuelinthetank
3. Airbubbleinthefuelline
4. FuelvalveinOFFposion
5. ChokenotON
6. Chokelinkageoutofadjustment
7. Loosesparkplugwire
8. Fouledsparkplug

9. Pluggedordirtyairfilter
10. Bad/oldgasoline

1. TurnkeytoONposion
2. Addgasoline
3. Primeengineorshakebubbleout
4. TurnvalveON
5. TurnchokeON
6. RefertoEngineOwner’sManual
7. Addengineoil 
8. Tightenwire
orconnecons
9. Cleanorreplacetheplug
10. Cleanorreplacetheairfilter
11. Drainandreplacewithfreshgasoline


Enginewillnotkeep
running/quits
1. Waterinthefuel
2. FuelvalveisOFF
3. Lowengineoil

1. Drainandreplacewithfreshfuel
2. TurnfuelvalveON
3. Addengineoil 
Augersdonotturn 1. Shearpinsholdingtheaugersmay
havesheared.
2. Ifthepinssheared,replacethemasneededaer
applyinglubricantintothesha.CallGXiParts&
Service
at1‐919‐550‐3221oremail:
[e-mail]for
parts.
Shaisnotturning 1. Shear‐Pinsholdingtheaugersmay
havesheared.
2. Checkthegearbox.
Ifthepinssheared,replacethemasneededaer
applyinglubricantintothesha.
CallGXiParts&Serviceat1‐
919‐550‐3221oremail:
[e-mail]forparts.
Snowbloweralwayspulls
tooneside
1. Skidshoesand/orscrapperblade
draggingmoreononesidethanthe
other
2. Airpressureinresisnotequalon
bothsides.

1. Adjustskidshoesand/orscrapperbladesothe
scrapperbladedragsuniformlyonthesurface
beingblown.
2. Checkairinres.Addorremovepressureas
needed.

Enginewillnotstart
withelectricstarter
1. Notusingpropergaugecord
2. Safetykeyisloose
3. Nopowerfromelectricalsource

1. Use120V16gaugecordingoodcondion.
2. Verifythesafetykeyisfullyinserted.
3. Checkbreakerandplugconnecons
Fuelisleakingfromthe
engine.
1. Primer
bulbwaspressedtoomany
mes.

2. Fuelhosehasbecomedis‐connected
3. Carburetorhascontaminantsinit
causingthebowltoflood.

1. Donotpressprimermorethan3mes.Wipeoff
excessfuelandallowtodryCOMPLETELYbefore
aempngtostart
2.
Re‐connectfuelhoseandclamp(s)
3. Fueltankandcarburetorneedstobeflushedand
carburetorneedscleaning.