PROFESSIONAL DEL REY HEATER Use and Care Guide and Installation Instructions MODELS: DCS-DRH48N Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo A MESSAGE TO OUR CUSTOMERS Thank you for selecting DCS Professional Del Rey Heater. Because of this appliance’s unique features we have developed this Use and Installation Guide. It contains valuable information on how to properly operate and maintain your new appliance for years of safe and enjoyable use. To help serve you better, please fill out and submit your Ownership Registration Card by visiting our website at www.dcsappliances.
Alfresco-Heating.com - - - 888-Warm-Glo TABLE OF CONTENTS SAFETY PRACTICES AND PRECAUTIONS ...................................................................................................3-4 CLEARANCES / INSTALLATION SPECIFICATIONS .................................................................................5-8 INSTALLATION ...............................................................................................................................................................9-10 LEAK TESTING .
Alfresco-Heating.com - - - 888-Warm-Glo SAFETY PRACTICES AND PRECAUTIONS When properly cared for, your Del Rey Heater will give safe, reliable service for many years. However, extreme care must be used since the heater produces intense heat and can increase accident potential. When using this appliance basic safety practices must be followed, including the following: Read this Care and Use Guide carefully and completely before using your heater to reduce the risk of fire, burn hazard or other injury.
Alfresco-Heating.com - - - 888-Warm-Glo SAFETY PRACTICES AND PRECAUTIONS Children should not be left alone or unattended in an area where the heater is being used. Never allow them to sit, stand or play on or around the heater at any time. When in use, portions of the heater get hot enough to cause severe burns. Never let clothing, or other flammable materials come in contact with or too close to any part of heater or hot surface until it has cooled. Fabric may ignite and result in personal injury.
Alfresco-Heating.com - - - 888-Warm-Glo CLEARANCES/INSTALLATION SPECIFICATIONS 00 INSTALLATION MINIMUM CLEARANCES TO COMBUSTIBLE MATERIAL. Side View Gas Pipe Combustible Surface Gas Shut-off (installer supplied) Valve (installer supplied) Four Bolts Two On Each Side (installer supplied) 1/2" Conduit 14" (installer supplied) (MIN) Drip Leg Utilize 2 bolts (min) per bracket. Utilize 2 bolts (min) per bracket. 7-3/4" 21"(MIN) 10-1/4" 96" (MIN) FLOOR Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo CLEARANCES 300 INSTALLATION MINIMUM CLEARANCES TO COMBUSTIBLE MATERIAL. Note: Mounting channels can be hacksawed 13” for use in 30 0 installations. SIDE VIEW Combustible Surface 4 bolts per bracket Gas Pipe 23" (installer supplied) min. 1/2" Conduit (installer supplied) Drip Leg Gas Shut-off (installer supplied) Valve (installer supplied) Utilize 2 bolts (min) per bracket. 10" 30 0 max. 96" Min Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo CLEARANCES 00 & 300 INSTALLATION (MINIMUM CLEARANCES TO COMBUSTIBLE MATERIAL). Front View Wall (Combustible Surface) Wall (Combustible Surface) Heater Mounting Body Assy. 18" 18" 48" min min 00 INSTALLATION (MINIMUM CLEARANCES TO NON-COMBUSTIBLE MATERIAL). SIDE VIEW Four Bolts Per Bracket Utilize 2 bolts (min) per bracket.
Alfresco-Heating.com - - - 888-Warm-Glo CLEARANCES 300 INSTALLATION MINIMUM CLEARANCES TO NON-COMBUSTIBLE MATERIAL. SIDE VIEW Four Bolts Per Side Non Combustible Surface Gas Pipe Gas Shut-off (installer supplied) Valve Utilize 2 bolts (min) per bracket. (installer supplied) 1/2" Conduit (installer supplied) Drip Leg 0 30 30 0 max. 96" min FLOOR Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo INSTALLATION INSTALLATION: The Del Rey Heater provides radiant warmth *indoors (commercial applications only) or outdoors with a powerful 58,000 Btu/hr natural gas. All units are equipped with hot surface ignition and 100% shutoff valve for safety. Del Rey Heaters to be installed in Aircraft Hangers must be installed in accordance with American National Standards for Aircraft Hangers, ANSI/NFPA No. 409.
Alfresco-Heating.com - - - 888-Warm-Glo INSTALLATION Do not locate either the gas or electrical supply line directly over the flue outlet of the heater. Electrical supply line shortage and / or control overheating may occur. The heater must be installed in a location such that it is accessible for servicing and have no restriction of air flow to the air inlet of the heaters casing. MOUNTING Each heater must be installed such that the minimum clearance to combustibles are maintained.
Alfresco-Heating.com - - - 888-Warm-Glo LEAK TESTING IMPORTANT: VENTILATION A minimum building ventilation rate of 4 CFM per 1,000 BTU’s of installed heater input must be provided. This rate of ventilation may be obtained through either gravity or mechanical ventilation of the building. In conjunction with building ventilation system, adequate fresh air into the building must be provided through fresh air inlets and/or building inlets.
Alfresco-Heating.com - - - 888-Warm-Glo LIGHTING/OPERATION INSTRUCTIONS LIGHTING INSTRUCTIONS Upon installation of the heater and completion of the gas line and electrical supply to each heater, follow the steps below for Lighting Instructions. Lighting instructions are also provided on the control panel of the heater. Turn gas and power to “ON”. The igniter should light within the first 4 seconds. If not, the electrode sensor will shut off the hot surface igniter.
Alfresco-Heating.com - - - 888-Warm-Glo CARE & CLEANING / BASIC TROUBLESHOOTING CARE AND CLEANING To keep your Del Rey Heater in maximum performance, we recommend the following to be perform annually. 1. With an air hose regulated to 30 psig, blow off any dust and dirt that has accumulated around the burner and inside the control compartment of the heater. Proper eye protection required. 2.
Alfresco-Heating.com - - - 888-Warm-Glo SERVICING REMOVAL OF BURNER Turn off gas and electrical before attempting any service to this appliance. Heater may be serviced by following instructions below: a. Remove the four screws on the control service panel. b. Remove the hex nut that is holding the orifice fitting to the infrared burner’s bracket. c. Remove the burner windscreen by removing the screw on the windscreen’s frame. Then pull the windscreen down and slowly slide it out. d.
Alfresco-Heating.com - - - 888-Warm-Glo GAS VALVE REPLACEMENT Turn off gas supply. Turn off electrical supply. Disconnect gas & electrical supply. Remove unit from hangers. Remove screws securing the rear panel and remove the panel. Use a 7/8” open end wrench to hold orifice nut. Remove the existing black pipe and install it in the new valve. Reverse disassembly order to install new valve. Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo GAS VALVE REPLACEMENT Reinstall (4) screws securing valve to case. Re-connect leads to valve. Be sure valve switch is on (in the up position). The transformer must be mounted outside of unit to protect it from the heat and ensure long service life. Refer to page 10. Do not install transformer inside unit. Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo HEATER PARTS LIST ITEM 1) 2) 3) 4) 5) 6) 7) 8) 9) 10) 11) 12) 13) DESCRIPTION Wall Plate R/H Mounting Channel Body Plate R/H Screws Back Panel Wall Plate L/H Mounting Channel Body Plate L/H Collector Box Mini Ingiter Control Valve Ignition Module Cover Remote Sensor Bracket PART NO.
120 VAC 60 Hz 18 ELECTRODE SENSOR MINI IGNITER NOTE: 1. PURPLE, FLAME SENSE (ELECTRODE SENSOR) 2. GREEN, GROUND 3. BLUE, TO VALVE HOT (LOCATION 1) 4. ORANGE, THERMOSTAT 5. KEY 6. BLACK, L1-24 VAC 7. RED IGNITER 24 VAC Ground Valve 1 2 7 4 2 1 969 FIG09.EPS IGNITION MODULE 6 3 Alfresco-Heating.com - - - 888-Warm-Glo WIRING DIAGRAM Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo YELLOW BK WT YELLOW BK BL RED PURPLE WIRING SCHEMATIC Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo WARRANTY LENGTH OF WARRANTY This warranty applies to appliances used in residential and commercial applications. One (1) Year Full parts and Labor Covers the entire product. Five (5) Year limited warranty on all stainless steel components (not including surface corrosion and discoloration). DCS WILL COVER: All repair labor and parts found to be defective due to materials or workmanship for one full year from date of purchase.
Alfresco-Heating.com - - - 888-Warm-Glo SERVICE HOW TO OBTAIN SERVICE: For warranty service, please contact your local service provider or DCS Customer Care Center at (888) 281-5698, Monday thru Friday, 6:00 am – 4:30 pm PST. Before you call, please have the following information ready: Model Number Serial Number Date of installation A brief description of the problem Your satisfaction is of the utmost importance to us.
Alfresco-Heating.com - - - 888-Warm-Glo NOTES Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo NOTES Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo NOTES Alfresco-Heating.
Alfresco-Heating.com - - - 888-Warm-Glo 5800 Skylab Road, Huntington Beach, CA 92647 Tel: 714.372.7000 • Fax: 714.372.7001 Customer Care Center: (888) 281-5698 www.dcsappliances.com As product improvement is an ongoing process at DCS, we reserve the right to change specifications or design without notice. Alfresco-Heating.com 888-Warm-Glo P/N 10955 Rev.
