Service manual

Raider Mini 90 (single/double-seat): Service Manual Version：2.0 Feb. 2006
10
2. MAINTENANCE
2.1 MAINTENANCE SCHEDULE
The maintenance interval in the follow table is based upon average riding conditions.
Riding in unusually dusty areas requires more frequent servicing.
Interval
Items
1
st
Service in
1
st
Week
Daily Monthly Quarterly Yearly
Air cleaner X X C R R
S
p
ark
p
lu
g
XC，AR R
Carburetor
AAA C
Gearbox oil X X R R
En
g
ine oil X X R R R
Tire
p
ressure/wea
r
XXXX R
Brake pad X X X R R
Drive chain CAL CAL CA
L
CA
L
CAL
Brake cable A A A A
Chassis X X X X
Fuel switch/fuel tan
k
XX X
Battery X X X R
Valve clearance of engine A A A
Throttle cable A A A A
Absorber X X X R
NOTE: X：inspect，clean or replace if necessary ; A: adjust;
C: clean; L: lubricate; R: replace.
2.2 Maintenance and Tune-Up Procedures
This section describes the servicing procedures of every item in the Periodic
Maintenance Intervals Table above.
2.2.1 Spark Plug
Clear up the carbon around the spark plug to prevent it from dripping into the cylinder
when removing the spark plug.
Remove the spark plug:
a) In general, it should be carried on after the engine has cooled down;
b) If the spark plug is too tight to remove, spray some rust inhibiter on the spark plug
washer and the thread part; after the inhibiter has soaked the washer and thread
part, rotate the spark plug;