Service manual

CHASSIS
Removal
Scribe
alignment
marks on hood around
hinges
and
remove hood from
hinges
2
Completely
drain coolant
engine
and
transmission
lubricant
3 Remove blow
by
hose from rocker cover and air
cleaner
4 Remove radiator
grille
5
Disconnect
battery
cable and remove
battery
off the
car
6
Take
off both
upper
and
lower radiator hoses Then
loosen
fIxing
bolts of radiator and take it out in
sequence
7
Disconnect
fuel
tube from
fuel
pump
8 If
equipped
with heater remove its hoses at
engine
attachment
9 Disconnect
accelerator control
linkage
and choke
wire
at
the carburetor side
10 Disconnect
wirings
for
starter alternator
ignition
coil
oil
pressure
switch
and thermal
transmitter
II Remove
clutch
operating cylinder
and
its relurn
spring
12 Disconnect
speedometer
cable
Disconnect flat
attaching plug
connector from
reverse
lamp
switch
13 Disconnect
shift
rod
and
select
rod
and
then
remove
cross
shaft
assembly by
removing
cross
shaft
bracket
from
side
member
14 Disconnect
front exhaust tube from
exhaust
manifold
15 Disconnect
propeller
shaft
by disconnecting
it
from
companion flange
of
gear
carrier
16
Jack
up
transmission a little
and then remove
rear
engine mounting
cross
member
by
removing
fixing bolts
of
engine mounting
insulator
mounting
cross
member and
hand brake
cable
clamp
17
Remove
bolts
securing
front
engine mounting
in
sulators to
cross
member
18 Hook with cable
or
chain to
stringers
hooks
which
are
installed
on
engine cylinder
head one at
the
front and
the other
at the
rear
Fig
ER J
Removing
clutch
operating cylinder
Fig
ER 4
Lifting engine for
the
J
1 J and
J15
engine
ER 2