Epicure ® Install ation Instructions Cooktop For Use with Models: EG366, EG486 Save These Instructions Part No. 102025 Rev. E THIS APPLIANCE HAS BEEN TESTED IN ACCORDANCE WITH THE LATEST EDITION OF ANSI Z21.1 STANDARD FOR HOUSEHOLD GAS APPLIANCES.
Table of Contents Before You Begin..........................................................................1 Important Safety Instructions...................................................1-3 General Safety Precautions ....................................................2 Customer Service Information.....................................................3 Planning the Installation............................................................4-7 Electrical Requirements..........................................
Important Safety Instructions General Safety Precautions To reduce the risk of fire, explosion, electric shock, serious injury or death when installing or using this appliance, follow basic safety precautions, including the following: WARNING 1. Read the accompanying use and care manual completely before operating this appliance. 2. Keep packaging materials away from children. Plastic sheets and bags can cause suffocation. 3.
Important Safety Instructions General Safety Precautions (Cont.) WARNING 27. IMPORTANT - This appliance is equipped with a three-prong grounding plug for your protection against possible electric shock hazards. It must be plugged into a dedicated, grounded receptacle. Where a standard two-prong wall receptacle is encountered, it is the personal responsibility and obligation of the customer to have it replaced with a dedicated, properly grounded three-prong wall receptacle.
Planning the Installation WARNING IMPORTANT: Observe all governing codes and ordinances during planning and installation. Contact your local building department for further information. Electrical Requirements • Product Dimensions It is the owner’s responsibility to ensure that the electrical receptacle for this appliance has been installed by a qualified electrician.
Planning the Installation Cabinet Layout WARNING • Carefully check the location where the cooktop is to be installed. For best performance, the cooktop should be placed away from drafts that may be caused by doors, windows and heating and air conditioning outlets. • To reduce the risk of personal injury and to reduce accumulated smoke in the room, Dacor strongly recommends installing a hood. A range hood should project horizontally a minimum of five (5) inches beyond the face of the cabinets.
Planning the Installation Cabinet Layout (continued) B Hood 10” (254mm) to combustible side wall minimum, both sides 30” (457mm) Minimum 1 12” (38mm) Typical countertop thickness 5/8” (16mm) Overhang, both sides 18” (457mm) 7 3/4” (197mm) C 2 3/4” (70mm) Cooktop platform 1” (25mm) Minimum thickness 15 1/2” (393mm) Gas and electrical service location 6” (152mm) D C L CUT-OUT DIMENSIONS Cooktop Model “B” “C” “D” EG366 36” (914mm)* 42” (1067mm)** 36” (914mm)* 24” (610mm) EG486 48” (1219m
Planning the Installation Cabinet Layout (continued) All tolerances: +1/16”, -0 (+1.6mm, -0) Non combustible rear wall 12 9/16” (319mm) 8” (203mm) Hole 2 Places, 1/2” Dia.
Installation Instructions Preparing for Installation Cooktop Installation IMPORTANT: Within the Commonwealth of Massachusetts, this appliance must be installed by a licensed plumber or gas fitter. caution • Gas and Electric Service Installation WARNING • For LP installations, the LP tank must have its own high pressure regulator. This is in addition to the pressure regulator provided with the cooktop.
Installation Instructions Cooktop Setup WARNING • Never attempt to operate the cooktop with any of the burner rings, burner caps or grates removed. Spill Tray Crown Burner Install the Burner Components NOTE: Do not attempt to adjust the burner air mixture settings. All adjustments are preset at the factory. • Remove the burner rings, burner caps and grates from their Stack Burner shipping packages. • • Install the burners as shown. Gently set the grates on top of the spill tray.
Installation Instructions Installing the Burner Knobs CAUTION Installing the cooktop knobs in the wrong position may result in damage to the cooktop griddle. The knobs for the center burners are marked with the maximum griddle settings. There are two (2) different types of knobs supplied with the cooktop. The knobs for the center burners have the words “MAX GRIDDLE” on them. • Put the knobs with the words “MAX GRIDDLE” on them onto the inner (center burner) valve shafts.
Installation Instructions Verifying Proper Operation Installation Checklist WARNING • Do not use an extension cord with this appliance. Such use may result in fire, electric shock or other personal injury. Prior to operating the cooktop, please read the accompanying use and care manual carefully. Important safety, service and warranty information is contained within the use and care manual. 1.
Notes 12
Notes 13
Specifications contained within are subject to change without notice. No liability is assumed by DACOR for changes in specifications. ® Web Site: Phone: www.Dacor.com (800) 793-0093 Copyright © 2007 Distinctive Appliances Inc. all rights reserved.
