SDS

Amperex Technology Limited
新能源科技有限公司
3503,Wharf Cable TV Tower, 9 Hoi Shing Road,Tsuen Wan,N.T, HongKong China
香港新界荃湾海盛路 9 号有线电视大楼 35 楼 3 号单元
Tel：[phone] Fax：[phone] http://www.ATLbattery.com
Issue: 2015-07 Doc No.: 2015-C-004
ATL confidential
Page 10 of 12
and signed as following table.（If the cell’s power less than 20Wh or battery’s power less than 100Wh and the
package according with PI-965 SectionⅡ，it is not classified as dangerous cargo）.
UN NO.
Proper Shipping
Name
Power
Package
requirements
Label which need to paste
UN3480
lithium ion batteries
Cell≤20Wh
Battery≤100Wh
PI965 Section IB
Class 9 hazard label and lithium
battery handling label
Cell＞20Wh
Battery＞100Wh
PI965 Section IA
Class 9 hazard label
Cell≤20Wh
Battery≤100Wh
PI965 Section Ⅱ
lithium battery handling label
Do not damage or mishandle this package. If package is damaged, batteries must be quarantined, inspected, and
repacked. Cells and batteries identified by the manufacturer as being defective for safety reasons, or that have been
damaged, that have the potential of producing a dangerous evolution of heat, fire or short circuit are forbidden for
transport .Waste lithium batteries and lithium batteries being shipped for recycling or disposal are prohibited from air
transport unless approved by the appropriate national authority of the State of origin and the State of the operator.
The lithium battery should pass the UN38.3 test, if the battery can not pass the testing, it can not transport, should
redesign. If the battery through the test, for the lithium battery only, follow the UN3480 and the packing requirements
for PI965, for the lithium battery which installed in equipment, follow the UN3481 and the packing requirements for
PI967.
The lithium battery testing meets all requirements under UN Manual of Tests and Criteria Part III, subsection 38.3.
Manual of Test and Criteria (38.3 Lithium batteries)
Test Results
Remark
No
Test item
T1
Altitude Simulation
Pass
T2
Thermal Test
Pass
T3
Vibration
Pass
T4
Shock
Pass
T5
External Short Circuit
Pass
T6
Impact/Crush
Pass
T7
Overcharge
Pass
For pack and single
cell battery only
T8
Forced Discharge
Pass
The requirement of ocean shipping
According to International Maritime Dangerous Goods Code(IMDG 37th) to transport and according to the
requirements of UN NO. 3480/3481 to management the goods, and require class II packaging. Firmly installation.
mutual isolation. avoid short circuits. If the package contain more than 24 lithium batteries or more than 12 lithium
battery packs, must provide the special program if package damage.
The clause 188 of IMDG require the Watt of lithium ion cell less than 20Wh is not classified as dangerous cargo
and the Watt of lithium ion battery less than 100Wh is not classified as dangerous cargo but need marked the WHR