Specifications

MAINTENANCE
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
5 - 14
5
BATTERY CHARGING AND MAINTENANCE
Batteries
To prevent battery explosion that could result in severe personal injury or death, keep all smok-
ing materials, open flames or sparks away from the batteries.
Hydrogen gas is formed when charging batteries. Do not charge batteries without adequate ven-
tilation. A 4% concentration of hydrogen gas is explosive.
Be sure that the key switch is off and all electrical accessories are turned off before starting work
on the vehicle.
Never disconnect a circuit under load at a battery terminal.
Batteries are heavy. Use proper lifting techniques when moving them.
Always lift the battery with a commercially available battery lifting device.
Use care not to tip batteries when removing or installing them; spilled
electrolyte can cause burns and damage.
The electrolyte in a storage battery is an acid solution which can cause
severe burns to the skin and eyes. Treat all electrolyte spills to the body
and eyes with extended flushing with clear water. Contact a physician
immediately.
Always wear a safety shield or approved safety goggles when adding water
or charging batteries.
Any electrolyte spills should be neutralized with a solution of 1/4 cup (60 ml)
sodium bicarbonate (baking soda) dissolved in 1 1/2 gallons (6 liters) of water
and flushed with water.
Overfilling batteries may result in electrolyte being spilled from the battery
during the charge cycle. Expelled electrolyte may cause damage to the vehi-
cle and storage facility.
Aerosol containers of battery terminal protectant must be used with extreme care. Insulate
metal container to prevent can from contacting battery terminals which could result in an
explosion.
Wrap wrenches with vinyl tape to prevent the possibility of a dropped wrench
from ’shorting out’ a battery, which could result in an explosion and severe per-
sonal injury or death.
BATTERY MAINTENANCE
Tool List Qty. Tool List Qty.
Insulated Wrench, 9/16"...............................................1 Battery Carrier ........................................................ 1
Hydrometer..................................................................1 Battery Maintenance Kit P/N 25587-G01................ 1
As a battery ages, it still performs adequately except that its capacity is diminished. Capacity describes the time that
a battery can continue to provide its design amperes from a full charge.
A battery has a maximum life, therefore good maintenance is designed to maximize the available life and reduce the
factors that can reduce the life of the battery.