Installation Guide

GROSS LOAD CAPACITY WHEN USED AS A WEIGHT CARRYING HITCH: LBS. TRAILER WEIGHT & LBS. TONGUE WEIGHT.
GROSS LOAD CAPACITY WHEN USED AS STRAIGHT LINE PULL: LBS. MAX. LINE PULL.
DO NOT EXCEED VEHICLE MANUFACTURER'S RECOMMENDED TOWING CAPACITY.***
HITCH WEIGHT: LBS.
INSTALL TIME:
MINUTES
INSTALL NOTES:
INSTALLATION STEPS
PERIODICALLY CHECK THIS RECEIVER HITCH TO ENSURE THAT ALL FASTENERS
ARE TIGHT AND THAT ALL STRUCTURAL COMPONENTS ARE SOUND.
Curt Manufacturing Inc., warrants this product to be free of defects in material and/or workmanship at the time of retail purchase by the original purchaser. If the product is found to be defective,
Curt Manufacturing Inc., may repair or replace the product, at their option, when the product is returned, prepaid, with proof of purchase. Alteration to, misuse of, or improper installation of
this product voids the warranty. Curt Manufacturing Inc.'s liability is limited to repair or replacement of products found to be defective, and specifically excludes liability for incidental or
consequential loss or damage.
5,000
500
29
30
9,000
Parts List
DESCRIPTIONPART NUMBERQTYITEM
.250 x 1.50 x 2.00" SQUARE HOLE SPACERCM-SP1
62
NUT, SER-FLANGE,1/2-13 UNC,GRD8,YZ
20-0006263
HHCS,M12x1.75,50,CL10.9
10-1045844
WASHER,S-CON,1/2,YZ
30-0014945
1/2" FISHWIRE1_2 FISHWIRE16
BOLT,CAR,1/2-13 UNC,1-3/4,GRD8,YZ10-102726
7
31042
**4 WHEEL DRIVE TRUCKS ONLY**
CHEVY/GMC TRUCKS, CHEVY SUBURBAN
CHEVY TAHOE, GMC YUKON, FULL SIZE BLAZER
4X4 MODELS WITH TOW HOOKS:
1) Remove tow hooks. Raise hitch into position and loosely fasten with two M12 fasteners supplied, each side.
2) Fishwire 1/2" carriage bolt and block, as shown, in hole toward rear of vehicle.
3) Fishwire 1/2" carriage bolts and blocks into all avalible holes, as shown.
4) Raise hitch into position and fasten with 1/2" flange nuts provided.
5) Torque all M12 fasteners to 86 lb.-ft. Torque all 1/2" fasteners to 110 lb.-ft.
Fishwire fasteners, some
models have weldnuts.
NO drilling required.
2
3
4
5
FRAME RAIL
EXISTING WELD NUTS
ON SOME MODELS.
TOW HOOKS ON
SOME MODELS.
8/4/2020