Product Manual
Table Of Contents
- Table of Contents
- 1. IMPORTANT SAFETY INSTRUCTIONS
- 1.1 Warning, Caution, and Note Styles Used in This Manual
- 1.2 General Information
- 1.3 Generator Set Safety Code
- 1.4 Moving Parts Can Cause Severe Personal Injury or Death
- 1.5 Electrical Shocks and Arc Flashes Can Cause Severe Personal Injury or Death
- 1.6 Fuel and Fumes Are Flammable
- 1.7 Batteries Can Explode
- 1.8 Exhaust Gases Are Deadly
- 1.9 The Hazards of Carbon Monoxide
- 1.10 Earth Ground Connection
- 2. Introduction
- 3. Control System
- 4. Operation
- 5. Maintenance
- 6. Troubleshooting
5. Maintenance 8-2019
80 A062J680 (Issue 2)Copyright © 2019 Cummins Inc.
CAUTION
Toxic Hazard
Electrolyte is a dilute sulphuric acid that is harmful to the skin and
eyes. It is electrically conductive and corrosive.
Wear full eye protection and protective clothing. If electrolyte contacts
the skins, wash it off immediately with water. If electrolyte contacts the
eyes, flush thoroughly and immediately with water and seek medical
attention. Wash spilled electrolyte with an acid neutralizing agent.
NOTICE
Keep batteries upright to prevent spillage.
Fire Hazard
WARNING
Combustible Gases
Lead acid batteries present a risk of fire because they generate
hydrogen gas.
Do not smoke near the batteries. Do not cause flame or spark in the
battery area. Discharge static electricity from your body before
touching batteries by first touching a grounded metal surface.
WARNING
Before disconnecting a battery, always remove power from the AC
powered battery charger.
WARNING
When putting a battery into service on a generator set, connect the
negative lead LAST; when removing the battery, disconnect the
negative lead FIRST.