Install Manual
Table Of Contents
- Table of Contents
- 1. Important Safety Instructions
- 1.1 Save These Instructions
- 1.2 General Information
- 1.3 General Precautions
- 1.4 Generator Set Voltage Is Deadly
- 1.5 Engine Exhaust Is Deadly
- 1.6 Fuel and Fumes Are Flammable
- 1.7 Batteries Can Explode
- 1.8 Starting Batteries
- 1.9 Moving Parts Can Cause Severe Personal Injury or Death
- 1.10 The Hazards of Carbon Monoxide
- 2. Introduction
- 3. Pre-Installation Considerations
- 4. Installation
- 5. Startup and Configuration
- 5.1 "Establishing Communications" Message
- 5.2 "Clock Setup" Screen
- 5.3 "Exercise" Screen
- 5.4 "Brightness and Contrast" Screen
- 5.5 "About" Screen
- 5.6 "Event Log" Screen
- 5.7 "Fault Log" Screen
- 5.8 "System Status" Screen
- 5.9 "Mode" Screen
- 5.10 Automatic Load Management
- 5.11 Manual Start Sequence (Local)
- 5.12 Checklist
- 5.13 Startup
- 6. Remote Monitoring System (RMS) Description
- Appendix A. Fuel Line Selection
- Appendix B. Outline and System Drawings
- Appendix C. Wiring Diagrams
2. Introduction8-2019
15A062J678 (Issue 2) Copyright © 2019 Cummins Inc.
TABLE 7. GENERATOR SET DERATING GUIDELINES
Model
Engine Power Available Up To... Derate At…
Elevation Ambient Temperature Elevation Temperature
C13N6H 2100 m (6900 ft) 25 °C (77 °F)
3.5% per
300 m
(1000 ft)
1% per
5.5 °C (10 °F)
C17N6H 300 m (1000 ft) 25 °C (77 °F)
C20N6H,
C20N6HC
0 m (0 ft) 15 °C (60 °F)
NOTICE
Derating guidelines: This product's output power is limited by factors such
as BTU content of fuel, ambient temperature, altitude, humidity, engine
condition, etc. The derating guidelines are based on properly maintained
product, using the appropriate fuel. Derate values are based on expected
engine power changes from elevation and temperatures listed.
TABLE 8. ALTERNATOR SPECIFICATIONS
Type Specification
Design Rotating field
Poles 2
RPM 3600
Voltage 240
Hz 60
TABLE 9. CONTROL SPECIFICATIONS
Control
Integrated Microprocessor-Based Engine, Alternator, Transfer Switch Controller
TABLE 10. DC SYSTEM SPECIFICATIONS
Type Value
Nominal Battery Voltage 12 VDC
Battery Group 51 R
Battery Type Lead Acid
Minimum Cold Crank Amps (CCA) 450