Install Manual
Table Of Contents
- Table of Contents
- 1. Important Safety Instructions
- 1.1 Save These Instructions
- 1.2 General Information
- 1.3 General Precautions
- 1.4 Generator Set Voltage Is Deadly
- 1.5 Engine Exhaust Is Deadly
- 1.6 Fuel and Fumes Are Flammable
- 1.7 Batteries Can Explode
- 1.8 Starting Batteries
- 1.9 Moving Parts Can Cause Severe Personal Injury or Death
- 1.10 The Hazards of Carbon Monoxide
- 2. Introduction
- 3. Pre-Installation Considerations
- 4. Installation
- 5. Startup and Configuration
- 5.1 "Establishing Communications" Message
- 5.2 "Clock Setup" Screen
- 5.3 "Exercise" Screen
- 5.4 "Brightness and Contrast" Screen
- 5.5 "About" Screen
- 5.6 "Event Log" Screen
- 5.7 "Fault Log" Screen
- 5.8 "System Status" Screen
- 5.9 "Mode" Screen
- 5.10 Automatic Load Management
- 5.11 Manual Start Sequence (Local)
- 5.12 Checklist
- 5.13 Startup
- 6. Remote Monitoring System (RMS) Description
- Appendix A. Fuel Line Selection
- Appendix B. Outline and System Drawings
- Appendix C. Wiring Diagrams
2. Introduction 8-2019
14 A062J678 (Issue 2)Copyright © 2019 Cummins Inc.
TABLE 4. ENGINE SPECIFICATIONS
Type Value
Engine
2 cylinder v-twin, OHV, air-cooled, 4-stroke, spark
ignited
Displacement 999 cc (60.9 in
3
)
Spark Plug Gap 0.38–0.58 mm (0.015–0.023 in)
Spark Plug Torque (Cold Engine) 25–30 Nm (18–22 ft-lb)
Magneto Gap 0.25–0.35 mm (0.010–0.014 in)
RPM 3600
Lubricating Oil Pressure at Rated
Speed (Minimum)
310 kPa (45 psi)
Oil Recommendation
Full synthetic gasoline engine oil which meets or
exceeds API service SN/SN-RC and ILSAC GF-5:
• 5W30: Temperatures above –17 °C (0 °F)
• 0W30: All temperatures, required below –17 °C (0
°F)
Lubricating Oil Capacity:
Lubricating Oil Pressure at Rated
Speed (Minimum)
310 kPa (45 psi)
--Full at High Mark on Dipstick 2.3 L (2.4 qt)
--Low Mark on Dipstick 1.3 L (1.4 qt)
TABLE 5. GENERATOR SET SIZE
Dimension Value
Length 865 mm (34.1 in)
Width 915 mm (36 in)
Height 694 mm (27.3 in)
TABLE 6. GENERATOR SET WET WEIGHT (INCLUDING BATTERY)
Model Value
C13N6H 218 kg (479 lb)
C17N6H, C20N6H, C20N6HC 241 kg (531 lb)