Install Manual
Table Of Contents
- Table of Contents
- 1. Important Safety Instructions
- 1.1 Save These Instructions
- 1.2 General Information
- 1.3 General Precautions
- 1.4 Generator Set Voltage Is Deadly
- 1.5 Engine Exhaust Is Deadly
- 1.6 Fuel and Fumes Are Flammable
- 1.7 Batteries Can Explode
- 1.8 Starting Batteries
- 1.9 Moving Parts Can Cause Severe Personal Injury or Death
- 1.10 The Hazards of Carbon Monoxide
- 2. Introduction
- 3. Pre-Installation Considerations
- 4. Installation
- 5. Startup and Configuration
- 5.1 "Establishing Communications" Message
- 5.2 "Clock Setup" Screen
- 5.3 "Exercise" Screen
- 5.4 "Brightness and Contrast" Screen
- 5.5 "About" Screen
- 5.6 "Event Log" Screen
- 5.7 "Fault Log" Screen
- 5.8 "System Status" Screen
- 5.9 "Mode" Screen
- 5.10 Automatic Load Management
- 5.11 Manual Start Sequence (Local)
- 5.12 Checklist
- 5.13 Startup
- 6. Remote Monitoring System (RMS) Description
- Appendix A. Fuel Line Selection
- Appendix B. Outline and System Drawings
- Appendix C. Wiring Diagrams
2. Introduction8-2019
11A062J678 (Issue 2) Copyright © 2019 Cummins Inc.
Abbr. Description Abbr. Description
EN European Standard PTC Power Transfer Control
EPS Engine Protection
System
PWM Pulse-Width Modulation
E-Stop Emergency Stop RFI Radio Frequency
Interference
FAE Full Authority Electronic RH Relative Humidity
FMI Failure Mode Identifier RMS Remote Monitoring
System
FSO Fuel Shutoff RMS Root Mean Square
Genset Generator Set RTU Remote Terminal Unit
GCP Generator Control Panel SAE Society of Automotive
Engineers
GND Ground scfh Standard Cubic Feet of
gas per Hour
HMI Human-Machine
Interface
SCR Selective Catalytic
Reduction
IC Integrated Circuit SPN Suspect Parameter
Number
ISO International Organization
for Standardization
SW_B+ Switched B+
LBNG Lean-Burn Natural Gas UL Underwriters
Laboratories
LCD Liquid Crystal Display UPS Uninterruptible Power
Supply
LCT Low Coolant
Temperature
2.3 Related Literature
Before any attempt is made to operate the generator set, the operator should take
time to read all of the manuals supplied with the generator set and familiarize
themselves with the warnings and operating procedures.