Install Manual
Table Of Contents
- Table of Contents
- 1. Important Safety Instructions
- 1.1 Save These Instructions
- 1.2 General Information
- 1.3 General Precautions
- 1.4 Generator Set Voltage Is Deadly
- 1.5 Engine Exhaust Is Deadly
- 1.6 Fuel and Fumes Are Flammable
- 1.7 Batteries Can Explode
- 1.8 Starting Batteries
- 1.9 Moving Parts Can Cause Severe Personal Injury or Death
- 1.10 The Hazards of Carbon Monoxide
- 2. Introduction
- 3. Pre-Installation Considerations
- 4. Installation
- 5. Startup and Configuration
- 5.1 "Establishing Communications" Message
- 5.2 "Clock Setup" Screen
- 5.3 "Exercise" Screen
- 5.4 "Brightness and Contrast" Screen
- 5.5 "About" Screen
- 5.6 "Event Log" Screen
- 5.7 "Fault Log" Screen
- 5.8 "System Status" Screen
- 5.9 "Mode" Screen
- 5.10 Automatic Load Management
- 5.11 Manual Start Sequence (Local)
- 5.12 Checklist
- 5.13 Startup
- 6. Remote Monitoring System (RMS) Description
- Appendix A. Fuel Line Selection
- Appendix B. Outline and System Drawings
- Appendix C. Wiring Diagrams
2. Introduction 8-2019
10 A062J678 (Issue 2)Copyright © 2019 Cummins Inc.
Abbr. Description Abbr. Description
ANSI American National
Standards Institute
Mil Std Military Standard
ASOV Automatic Shut Off Valve MPU Magnetic Pickup
ASTM American Society for
Testing and Materials
(ASTM International)
NC Normally Closed
ATS Automatic Transfer
Switch
NC Not Connected
AVR Automatic Voltage
Regulator
NFPA National Fire Protection
Agency
AWG American Wire Gauge NO Normally Open
CAN Controlled Area Network NWF Network Failure
CB Circuit Breaker OEM Original Equipment
Manufacturer
CE Conformité Européenne OOR Out Of Range
CCA Cold Cranking Ampere OORH/
ORH
Out Of Range High
CFM Cubic Feet per Minute OORL/ORL Out Of Range Low
CGT Cummins Generator
Technologies
PB Push Button
CMM Cubic Meters per Minute PCC PowerCommand
®
Control
CT Current Transformer PGI Power Generation
Interface
DC Direct Current PGN Parameter Group
Number
DEF Diesel Exhaust Fluid PI Proportional/Integral
DPF Diesel Particulate Filter PID Proportional/Integral/
Derivative
EBS Excitation Boost System PLC Programmable Logic
Controller
ECM Engine Control Module PMG Permanent Magnet
Generator
ECS Engine Control System PPE Personal Protective
Equipment
EMI Electromagnetic
Interference
PT Potential Transformer