Install Manual
Table Of Contents
- Table of Contents
- 1. Important Safety Instructions
- 1.1 Save These Instructions
- 1.2 General Information
- 1.3 General Precautions
- 1.4 Generator Set Voltage Is Deadly
- 1.5 Engine Exhaust Is Deadly
- 1.6 Fuel and Fumes Are Flammable
- 1.7 Batteries Can Explode
- 1.8 Starting Batteries
- 1.9 Moving Parts Can Cause Severe Personal Injury or Death
- 1.10 The Hazards of Carbon Monoxide
- 2. Introduction
- 3. Pre-Installation Considerations
- 4. Installation
- 5. Startup and Configuration
- 5.1 "Establishing Communications" Message
- 5.2 "Clock Setup" Screen
- 5.3 "Exercise" Screen
- 5.4 "Brightness and Contrast" Screen
- 5.5 "About" Screen
- 5.6 "Event Log" Screen
- 5.7 "Fault Log" Screen
- 5.8 "System Status" Screen
- 5.9 "Mode" Screen
- 5.10 Automatic Load Management
- 5.11 Manual Start Sequence (Local)
- 5.12 Checklist
- 5.13 Startup
- 6. Remote Monitoring System (RMS) Description
- Appendix A. Fuel Line Selection
- Appendix B. Outline and System Drawings
- Appendix C. Wiring Diagrams
9A062J678 (Issue 2) Copyright © 2019 Cummins Inc.
2 Introduction
2.1 About This Manual
WARNING
Improper installation can result in severe personal injury, death and damage
to equipment. The installation must comply with all applicable building
codes (including project permits and inspections). The installer should be
properly trained and licensed to perform electrical and mechanical
equipment installations (including gaseous fuel installation).
NOTICE
Manuals are updated from time to time to reflect changes in the equipment
and its specifications. The most up-to-date version of this manual is found
on the QuickServe website
(https://quickserve.cummins.com/info/index.html).
This manual is a guide for the installation of the generator set models listed on the
front cover. Proper installation is essential for top performance, reliable operation,
and safety. Read through this manual before starting the installation. These product
must only be installed outdoors.
NOTICE
The installation must comply with all applicable building codes.
See the generator set's specific operator manual for operation and maintenance and
specific service manual for service.
Refer to the Model Specifications section for specific information about the system
and its components.
Refer to the Outline and System Drawings appendix and the Wiring Diagrams
appendix for specific information about installation and wiring connections.
2.2 Schedule of Abbreviations
This list is not exhaustive. For example, it does not identify units of measure or
acronyms that appear only in parameters, event/fault names, or part/accessory
names.
Abbr. Description Abbr. Description
AC Alternating Current LED Light-Emitting Diode
AMP AMP, Inc. (part of Tyco
Electronics)
MFM Multifunction Monitor