User Guide

&5266.$7( 
WP
#ROSSKATE)NC
2"ESSOM3T
-ARBLEHEAD-!
#2/33+
ZZZFURVVNDWHFRP
0LEASEREFERTOTHE/WNERS-ANUALTHATCAMEWITHYOURSKATES
FOROTHERIMPORTANTMECHANICALSAFETYANDUSERINFORMATION
$ISCONNECTRATCHETCLASPFROMSTRAPONBOOT
2EMOVERATCHETCLASPMMHEXKEYANDMMWRENCHORPLIERSANDCABLE
ENDCRIMPPLIERS
2EMOVETHEBRAKEDISCSCREWSANDTHEREARWHEELSCREWMMHEXKEY
2EMOVEREARWHEELYOUCANLEAVETHEBRAKEDISCONTHEAXLE
3LIPBRAKECABLEOUTOFTHEENDSOFTHEBRAKEARMS
 0ULL BRAKE LINE ASSEMBLY OFF OF SKATE AND DISCARD #UT THE CABLE IF IT IS NOT
ALREADYSEVERED./4%9OUWILLNOTNEEDANYOFTHEOLDPARTS
)NSTRUCTIONS#ONTINUEDON"ACK
TOOLSREQUIRED
4HREADCABLETHROUGHTHEHOLEINTHEFRAMEAND
AROUNDPULLEYUSEASMALLALLENKEYORPENTOPOKE
CABLEUPAROUNDTHEFRONTOFTHEPULLEY
 4HREAD THE CABLE UNDERTHE METAL FINGER THAT
COVERSTHETOPOFTHEPULLEYSOTHATTHECABLEPOINTS
BACKTOWARDTHEBOOT
2EINSTALLREARWHEELANDBRAKEDISC
v3LIDE WHEEL ON AND POSITION BRAKEDISC DISC
MUST NOTBE PINCHED BETWEEN WHEEL AND
FRAME
v3TARTREARWHEELSCREWUNTILlNGERTIGHT
v)NSTALLBRAKEDISCSCREWSMMHEXKEY
v4IGHTENREARWHEELSCREWMMHEXKEY
5SINGTHEBRAKEOFFSETSCREWCENTERTHEBRAKES
MMHEXKEY4HEWHEELSHOULDSPINFREELYWITH
NOTENSIONINTHEBRAKECABLE
4HENEWBRAKECABLEHASTWOKINKSNEARTHEEND
0OSITION THE CABLE BETWEEN THE CLASP AND WASHER
AND INSTALL RATCHET CLASP AT THE KINK CLOSEST TO THE
ENDOFTHECABLEMMHEXKEYANDMMWRENCH
ORPLIERS4HENUTMUSTBEVERYTIGHTFORTHECABLE
TOBESECURE
3LIDETHENEWCABLEENDCRIMPONTOTHECABLEAND
CRUSHITWITHPLIERS
!DJUSTBRAKES#OARSEADJUSTWITHRATCHETCLASP
lNEADJUSTWITHBARRELINNOODLE

CPULLTHE
CABLE
AFEEDTHE
CABLEIN
BPOKE
THECABLE
UP
#ROSSKATE"ACKCOUNTRY
4-
"RAKELINE
2EPLACEMENT)NSTRUCTIONS
4OOLS2EQUIRED
v(EX+EYSMMMMMM
vMMWRENCH
v0LIERS
#ROSSKATE"ACKCOUNTRY
4-
"RAKELINE
2EPLACEMENT)NSTRUCTIONS
4HE "RAKELINE 2EPLACEMENT +IT CONSISTS OF TWO  PREASSEMBLED
BRAKELINESANDCABLEENDCRIMPS)NSTALLBOTH"RAKELINESATTHESAME
TIMETOENSUREPROPERBRAKINGPERFORMANCE
)FYOUNEEDADDITIONALSUPPORTCALL#ROSSKATE#2/33+
2EADALLINSTRUCTIONSCAREFULLYBEFOREYOUBEGIN
L
 3LIP CABLE INTO ARMS WSPRING IN
BETWEENLIKETHEOLDONEWAS-AKE
SURE THE CABLEEND AND NOODLE ARE
WELLSEATEDINTHEBRAKEARMS
)NSERTCABLEHOUSINGINTOCABLESTOP
ON THE FRAME AND PULL THE ALUMINUM
CABLECRIMPFORWARDTOTHEOTHERSIDE
OFTHECABLESTOPSOTHATTHEHOUSING
AND CABLECRIMP SANDWICH THE CABLE
STOP
"RAKELINE)NSTALLATION
TOOLSREQUIRED
"RAKELINE2EMOVAL
#ONTINUEDFROM&RONT
"RAKELINE)NSTALLATION
L
4ESTRIDEINA3!&%0,!#%
TOOLSREQUIRED

4.
feed the cable
under the finger
7.
Attach ratchet clasp at last kink
