Product Manual
STORAGE AND TRANSPORT
!
DANGER: FIRE OR EXPLOSION - Gasoline is highly
ammable and extremely explosive. Empty the fuel tank
and shut o fuel valve before storing or transporng this
pump.
1. STORAGE - The pump should be started at least once
every 2 weeks and allowed to run for at least 20
minutes.
2. LONG TERM STORAGE - Follow the instrucons below
for if the pump is not being used with in the next 2
months or longer.
I. Remove oil as maintenance and service chapter
indicate when pump engine is hot aer running.
Ii. Allow the pump to cool completely.
Iii. Drain all fuel completely from the fuel tank, fuel
hose and carburetor.
Iv. Remove spark plug and pour about 1 oz. of engine
oil into cylinder. Reinstall spark plug. Crank pump
slowly to distribute oil and lubricate cylinder.
V. Pull the recoil ll resistance is felt.
Vi. Remove the water outlet plug, and clean the pump
with pure water, and then drain all the water before
reaach the plug.
Vii. Clean the appearance of the pump and shield the
pump in case of dusty accumulaon.
Viii. Store the unit in a clean, dry area, and out of direct
sunlight.
3. TRANSPORTATION - To prevent fuel spillage, when
transporng or during temporary storage, the pump
should be secured upright in its normal operang
posion, with the all switches in the OFF posion.
!
DANGER: When transporng: Do not over ll the
tank. Avoid a place exposed to direct sunlight when
pung the pump on a vehicle. If the pump is le in
an enclosed vehicle for many hours, high temperature
inside the vehicle could cause fuel to vaporize resulng
in a possible explosion.
!
CAUTION: Do not drive on a rough road for an
extended period with the engine on board. If you must
transport the engine on a rough road, drain the fuel from
the engine beforehand.
Pg. 23