SDS

ManualsBrandsCRC ManualsCleaning Chemicals & Lubricants50 State Formula Brakleen Brake Parts Cleaners - 20 oz Aerosol Can - - Pkg Qty 12

SAFETY DATA SHEET

1. Identification

Product identifier Brakleen® Non-Chlorinated Brake Parts Cleaner

Other means of identification

Product code

05050

Recommended use

Brake parts cleaner

Recommended restrictions

None known.

Manufacturer/Importer/Supplier/Distributor information

Manufactured or sold by:

Company name

CRC Industries, Inc.

Address

885 Louis Dr.

Warminster, PA 18974 US

Telephone

General Information

215-674-4300

Technical

Assistance

800-521-3168

Customer Service

800-272-4620

24-Hour Emergency

800-424-9300 (US)

(CHEMTREC)

703-527-3887 (International)

Website

www.crcindustries.com

2. Hazard(s) identification

Category 1Flammable aerosols

Physical hazards

Compressed gasGases under pressure

Category 2ASerious eye damage/eye irritation

Health hazards

Category 3 narcotic effectsSpecific target organ toxicity, single exposure

Category 1Aspiration hazard

Category 2Hazardous to the aquatic environment, acute

hazard

Environmental hazards

Category 3Hazardous to the aquatic environment,

long-term hazard

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Extremely flammable aerosol. Contains gas under pressure; may explode if heated. May be fatal if

swallowed and enters airways. Causes serious eye irritation. May cause drowsiness or dizziness.

Toxic to aquatic life. Harmful to aquatic life with long lasting effects.

Precautionary statement

Prevention

Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not spray on an open

flame or other ignition source. Do not apply while equipment is energized. Pressurized container:

Do not pierce or burn, even after use. Extinguish all flames, pilot lights and heaters. Vapors will

accumulate readily and may ignite. Use only with adequate ventilation; maintain ventilation during

use and until all vapors are gone. Open doors and windows or use other means to ensure a fresh

air supply during use and while product is drying. If you experience any symptoms listed on this

label, increase ventilation or leave the area. Avoid breathing mist or vapor. Avoid breathing gas.

Wear eye/face protection. Wash hands thoroughly after handling. Avoid release to the

environment.

Response

If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. If inhaled:

Remove person to fresh air and keep comfortable for breathing. Call a poison center/doctor if you

feel unwell. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if

present and easy to do. Continue rinsing. If eye irritation persists: Get medical attention.

Storage

Store in a well-ventilated place. Store locked up. Protect from sunlight. Do not expose to

temperatures exceeding 50°C/122°F. Exposure to high temperature may cause can to burst.

1 / 9

Material name: Brakleen® Non-Chlorinated Brake Parts Cleaner

1809 Version #: 01 Issue date: 03-04-2014

SDS US

Summary of content (9 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Brakleen® Non-Chlorinated Brake Parts Cleaner Other means of identification Product code 05050 Recommended use Brake parts cleaner Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Manufactured or sold by: Company name Address Telephone General Information Technical Assistance Customer Service 24-Hour Emergency (CHEMTREC) Website CRC Industries, Inc. 885 Louis Dr.
PAGE 2
Disposal Hazard(s) not otherwise classified (HNOC) Dispose of contents/container in accordance with local/regional/national regulations. Static accumulating flammable liquid can become electrostatically charged even in bonded and grounded equipment. Sparks may ignite liquid and vapor. May cause flash fire or explosion. Supplemental information 8.49% of the mixture consists of component(s) of unknown acute hazards to the aquatic environment. 8.
PAGE 3
Methods and materials for containment and cleaning up Environmental precautions Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. Stop the flow of material, if this is without risk. Collect spillage. Dike far ahead of spill for later disposal. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination.
PAGE 4
US. ACGIH Threshold Limit Values Components Type Value TWA 400 ppm US.
PAGE 5
Upper/lower flammability or explosive limits 1.1 % estimated Flammability limit - lower (%) Flammability limit - upper (%) 12.8 % estimated Vapor pressure 5061 hPa estimated Vapor density > 2 (air = 1) Relative density 0.84 estimated Solubility (water) Slightly soluble. Partition coefficient (n-octanol/water) Not available. Auto-ignition temperature 539.6 °F (282 °C) estimated Decomposition temperature Not available. Viscosity (kinematic) Not available. Percent volatile 91.
PAGE 6
Prolonged skin contact may cause temporary irritation. Repeated exposure may cause skin dryness or cracking. Causes serious eye irritation. Skin corrosion/irritation Serious eye damage/eye irritation Respiratory sensitization Not available. Skin sensitization This product is not expected to cause skin sensitization. Germ cell mutagenicity No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic.
PAGE 7
Contaminated packaging Empty containers should be taken to an approved waste handling site for recycling or disposal. Since emptied containers may retain product residue, follow label warnings even after container is emptied. 14.
PAGE 8
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130) Not regulated. Not regulated. Safe Drinking Water Act (SDWA) Drug Enforcement Administration (DEA). List 2, Essential Chemicals (21 CFR 1310.02(b) and 1310.04(f)(2) and Chemical Code Number Acetone (CAS 67-64-1) 6532 Drug Enforcement Administration (DEA). List 1 & 2 Exempt Chemical Mixtures (21 CFR 1310.
PAGE 9
Consumer products (40 CFR 59, Subpt. C) State Consumer products Not regulated This product is regulated as a Brake Cleaner. This product is compliant for use in all 50 states. VOC content (CA) 9.2 % VOC content (OTC) 9.