Delivery Information

ManualsBrandsCosmo ManualsAppliances24 in. Top Control Built-In Tall Tub Dishwasher in Fingerprint Resistant Stainless Steel

Contents

IMPORTANT SAFETY INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

BEFORE YOU BEGIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Preparing to install your dishwasher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Enclosure requirements

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Drain requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Drain preparation

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Electrical requirements. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

GROUNDING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Cabinet preparation and wire routing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Preparing the hot water line. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Connecting the water line to the water supply

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . .

Installation instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Step 1: Check the door balance

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Step 2: Adjust the leveling legs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 4: Install the power cord. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 4: Install the power cord. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 5: Install the 90° water supply elbow. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 6: Install the drain hose. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 7: Inserting the drain hose through the cabinet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . .1

Step 8: Slide the dishwasher partially into the cabinet

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . .1

Step 9: Position the dishwasher under the countertop. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . .1

Step 9: Position the dishwasher under the countertop. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . .1

Step 10: Level the dishwasher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 11: Securing the dishwasher to the countertop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . .1

Step 12: Connecting the water supply line . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 13: Connecting the drain hose. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

Step 14: Connecting the electrical power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . .2

Step 15: Performing a pre-test check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Step 16: Wet testing the dishwasher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Step 17: Replacing the toekick. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

This installation guide will show you how to install your new dishwasher.

IMPORTANT SAFETY INSTRUCTIONS

CAUTION

RISK OF ELECTRIC SHOCK

DO NOT OPEN

This symbol indicates that dangerous

voltage constituting a risk of electric shock

is present within your dishwasher.

This symbol indicates that there are

important operating and maintenance

instructions in the literature

accompanying your dishwasher.

Summary of content (22 pages)

PAGE 1
Contents IMPORTANT SAFETY INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 BEFORE YOU BEGIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 Preparing to install your dishwasher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 2
Top Control Dishwasher BEFORE YOU BEGIN Read these instructions completely and carefully. IMPORTANT – Observe all governing codes and ordinances. • Note to Installer – Be sure to leave these instructions for the consumer’s and local inspector’s use. • Note to Consumer – Keep these instructions with your User Guide for future reference. • Skill Level – Installation of this dishwasher requires basic mechanical and electrical skills. Proper installation is the responsibility of the installer.
PAGE 3
Preparing to install your dishwasher Parts supplied: Wood screws (4) Hose clamp Top mounting clips (2) Drain hose Tools needed: Level Phillips screwdriver 1/4 in. and 5/16 in. Nut driver Adjustable wrench Flashlight Gloves Carpenters square Bucket New installations only Measuring tape Safety glasses Hole saw set Tubing cutter Drill and bits Materials needed: 90° Elbow, ferrule and compression nut. (3/8 NPT external thread on one end.
PAGE 4
Top Control Dishwasher Enclosure requirements • • • • The rough cabinet opening must be at least 24 in. (60.96 cm) deep. The maximum height of the opening is 35 in. (88.9 cm). The dishwasher must be installed so that the drain hose is no more than 10 feet (3.01 m) in length, for proper drainage. The dishwasher must be fully enclosed on the top, sides, and back, and must not support any part of the enclosure. 90° 90° 34” (86.36 cm) min. to 35” (88.9 cm) max. 18” (45.72 cm) 18” (45.72 cm) 3” (7.
PAGE 5
Drain requirements • • • • • Follow all local codes and ordinances. Do not exceed 10 ft. (3.01 m) of drain hose. Do not connect the drain lines from other devices to the dishwasher drain hose. The dishwasher must be connected to a waste line with an air gap (not provided) or a 32 in. (81.28 cm) high (min.) drain loop, depending on local codes and ordinances, to prevent back flow into the dishwasher. An air gap must be used if the waste tee or garbage disposal connection is less than 18 in. (45.
PAGE 6
Top Control Dishwasher Electrical requirements • • • This appliance must be supplied with 120V, 60 Hz., and connected to its own, properly grounded branch circuit, protected by a 15 or 20 ampere circuit breaker or time delay fuse. Wiring must be two wire with ground. If the electrical supply does not meet the above requirements, call a licensed electrician before proceeding. Warning FOR PERSONAL SAFE TY: Remove the house fuse or open the circuit breaker before beginning the installation.
PAGE 7
• Cable direct connections may pass through the same hole as the drain hose and hot water line, but power cords with plugs must pass through a separate hole. 1-1/2 in. (3.81 cm) diameter hole (max.) 2-1/2-3-1/2 in. (6.5-9.0 cm) from cabinet 24 in. (60.
PAGE 8
Top Control Dishwasher Preparing the hot water line • • • • The water connection is on the left side of dishwasher. The hot water line may enter the opening from either side, the rear, or the floor within the shaded area. The hot water line may pass through the same hole as the electrical and drain hose. Or, you can drill an additional 1-1/2 in. (3.81 cm) maximum diameter hole for the hot water line.
PAGE 9
Installation instructions Step 1: Check the door balance Caution • Opening the door of your dishwasher before it is installed will cause it to tip forward. Do not open the door until you are ready to install your dishwasher. • If it is necessary to open the door, hold the top of the dishwasher securely with one hand and hold the door with the other hand. 1 Hold the top of the dishwasher firmly. 2 Open the door slowly, then release it. If the door drops, increase the spring tension.
PAGE 10
Top Control Dishwasher Step 2: Adjust the leveling legs 1 Move the dishwasher close to the installation location and lay it on its back. 2 Measure the installation height and the dishwasher height. 3 Extend the leveling legs out from the dishwasher base 1/4 in. (6.35 mm) less than the installation height. Adjust to 1/4 in. (6.35 mm) less than the installation height. Adjust to 1/4 in. (6.35 mm) less than the installation height.
PAGE 11
Step 4: Install the power cord Skip this step if the dishwasher will be direct wired. 1 Remove the junction box cover on the right front of the dishwasher. 2 Connect the incoming white (or ribbed) wire to the dishwasher’s white wire, the black (or smooth) wire to the dishwasher’s black wire, and the ground wire to the dishwasher’s green wire. Use cUL/UL listed wire nuts of the appropriate size. 3 Replace the junction box cover on the right front of the dishwasher.
PAGE 12
Top Control Dishwasher Step 6: Install the drain hose 1 Turn the dishwasher upright. 2 Slide a screw-type hose clamp onto the drain hose. 3 Install the drain hose to the dishwasher drain outlet on the back of the dishwasher, then tighten the screw-type hose clamp.
PAGE 13
Step 7: Inserting the drain hose through the cabinet • Insert the drain hose into the hole in the cabinet wall. If a power cord is used, guide the end through a separate hole. Tip: Position the water line and house wiring on the floor to avoid interfering with the base of the dishwasher. Maximum drain hose length 10 ft. (3.
PAGE 14
Top Control Dishwasher Step 8: Slide the dishwasher partially into the cabinet Caution: Do not push against the front panel with your knees. Damage will occur. 1 Position the dishwasher in front of the opening, then slide the dishwasher into the opening a few inches at a time. 2 Pull the drain hose through the opening under the sink as you proceed. Stop when the dishwasher is a few inches in front of the adjacent cabinetry.
PAGE 15
Step 10: Level the dishwasher IMPORTANT: The dishwasher must be level for proper dish rack operation and wash performance. 1 Open the door, then place a level on the door and on the rack track inside the tub to make sure that the dishwasher is level. Check front-to-back level Check side-to-side level 2 Level the dishwasher by adjusting the four leveling legs individually. Tip: Pull the lower rack out about halfway. Make sure that the rack does not roll forward or back into the dishwasher.
PAGE 16
Top Control Dishwasher Step 11: Securing the dishwasher to the countertop • • • For countertops made of wood or materials that won’t be damaged by drilling, use Method 1. For countertops made of granite, marble, or other materials that could be damaged by drilling, use Method 2. If the gap between the control panel and the cabinet is less than 0.4 in. (10 mm), use method 2 Method 1 1 Insert the long top mounting clips into the slot. 2 Bend the brackets to secure them to the dishwasher tub.
PAGE 17
Step 12: Connecting the water supply line 1 Slide the compression nut, then the ferrule over the end of the water supply line. 2 Insert the water supply line into the 90° elbow. 3 Slide the ferrule against the 90° elbow and secure it with the compression nut. Ferrule Compression nut Water supply line 90° elbow Make sure that the door spring does not rub or contact the water supply line or drain IMPORTANT: hose. Test by opening and closing the door. Reroute the lines if interference occurs.
PAGE 18
Top Control Dishwasher Step 13: Connecting the drain hose IMPORTANT: Follow all local codes and ordinances. 1 Cut on the marked line as required for your installation. The drain hose’s molded end will fit 5/8”, 3/4” or 1" diameter connections on the air gap, waste tee, or garbage disposal. Cutting lines IMPORTANT: Do not cut corrugated portion of hose 2 If a longer drain hose is required, you can add up to 42" (1.1 m) of length, for a total of 10 ft. (3.01 m) to the factory installed hose.
PAGE 19
Method 2 - High drain loop to a waste tee or garbage disposal Fasten to the underside of the countertop Fasten to the underside of the countertop 18 in. (45.72 cm) minimum 32 in. (81.28 cm) minimum Waste tee installation 18 in. (45.72 cm) minimum 32 in. (81.28 cm) minimum Garbage disposal installation 4 If connecting the drain line to a garbage disposal, make sure that the drain plug has been removed. Your dishwasher will not drain if the plug is left in place.
PAGE 20
Top Control Dishwasher Step 14: Connecting the electrical power Turn off the electricity to the dishwasher’s electrical circuit. Skip this step if your dishwasher is equipped with a power cord. Make sure that the electrical power is turned off at the source. Warning • If your house wiring is not 2-wire with a ground, a ground must be provided by the installer. • If your house wiring is aluminum, be sure to use cUL/UL Listed anti-oxidant compound and aluminum-to-copper connectors.
PAGE 21
Step 15: Performing a pre-test check • • • • • • • • • • • • • • Review this list after installing your dishwasher to avoid problems or charges for a service call not covered by your warranty. Make sure that power is turned OFF. Open the door and remove all foam and paper packaging. Locate the User Guide in the literature package. Read the User Guide for operating instructions. Check the door opening and closing. If the door does not open and close freely, or tends to fall, check the spring adjustments.
PAGE 22
Top Control Dishwasher Step 17: Replacing the toekick • Place the toekick against the legs of the dishwasher. The slots should align with the toekick bracket screw holes. Allow the toekick to touch the floor. Install the toekick screws. You’ll need: Phillips screwdriver Specifications Capacity Max 16 place settings Dimensions (WxDxH) Bar handle unit - 23.9 x 26.5 x 33.7 in. (606 x 674 x 857 mm) Recess handle unit - 23.9 x 24.5 x 33.7 in. (606 x 623 x 857 mm) Weight Bar handle unit - 91.5 lbs. (41.