IMPORTANT WARRANTY & INSTALLATION INSTRUCTIONS ATTACHED Please Forward All Attached Information to Consumer Warranty Not Valid Unless Returned to CORSA Performance We ask that you take a few moments to complete our warranty registration form: TO ACTIVATE YOUR LIMITED LIFETIME WARRANTY GO TO: CORSAPERFORMANCE.COM/WARRANTY STOP For Full-Color Installation Instructions, Please Visit: CORSAPERFORMANCE.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC Please take time to read and understand these installation instructions. CORSA recommends that the installation of this system be performed by a qualified service center or professional muffler installer who has the necessary equipment, tools and experienced personnel.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC Factory Exhaust System Removal: 1. Using a 15mm deep socket and 3/8” drive ratchet, loosen the two clamps on the axle pipes located just over the rear axle downstream of the rear muffler. (Fig. A) Using a screw driver pry open the spring clip holding the locating pin on the driver and passenger side tailpipes. (Fig. B) 2.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC Factory Exhaust Removal Pictures Fig. A Fig. B Fig. C Fig. D Fig. E Fig. F CONTINUED ON NEXT PAGE INS5351 06/02/17 CORSA Performance · 140 Blaze Industrial Pkwy · Berea, OH 44017 · P: (440) 891.0999 · F: (440) 891-1868 E - Ma il : s al es @ C OR S A p e rf o rm a n ce .c om · ww w. CO RS A p e rf o rm a nc e.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC Factory Exhaust Removal Pictures Fig. G Fig. H Fig. I Fig. J Fig. K INS5351 06/02/17 CORSA Performance · 140 Blaze Industrial Pkwy · Berea, OH 44017 · P: (440) 891.0999 · F: (440) 891-1868 E - Ma il : s al es @ C OR S A p e rf o rm a n ce .c om · ww w. CO RS A p e rf o rm a nc e.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC Installation of CORSA Exhaust System: NOTE: Apply the anti-seize lubricant (supplied) to the threads ONLY of all the clamps and flange bolts. Failure to follow this procedure can cause nuts to seize on clamps and potentially destroy threads. After applying anti-seize lubricant, be sure to thoroughly clean your hands, as lubricant will tarnish stainless steel.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC 5. Locate the passenger side axle pipe assembly along with a 3” clamp and the corresponding stock axle pipe hanger grommet assembly. Install the hanger grommet assembly onto the axle pipe hanger in the same orientation at it was removed from the stock axle pipe hanger. (Fig. P) Next, slide the expanded end of the axle pipe over the passenger side muffler outlet pipe. (Fig.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC 10. Repeat the previous step for the driver side of the vehicle. 11. Visually inspect the exhaust system position, tip alignment, clamp orientation and position, and exhaust pipe clearance. Make any necessary adjustments at the slip joints. Inspect the heat shields on the driver side axle pipe, and passenger and driver side tailpipe assemblies.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC CORSA Exhaust Installation Pictures Fig. L Fig. M Fig. N Fig. O Fig. P Fig. Q CONTINUED ON NEXT PAGE INS5351 06/02/17 CORSA Performance · 140 Blaze Industrial Pkwy · Berea, OH 44017 · P: (440) 891.0999 · F: (440) 891-1868 E - Ma il : s al es @ C OR S A p e rf o rm a n ce .c om · ww w. CO RS A p e rf o rm a nc e.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC CORSA Exhaust Installation Pictures: Fig. R Fig. S Fig. T Fig. U Fig. V Fig. W CONTINUED ON NEXT PAGE INS5351 06/02/17 CORSA Performance · 140 Blaze Industrial Pkwy · Berea, OH 44017 · P: (440) 891.0999 · F: (440) 891-1868 E - Ma il : s al es @ C OR S A p e rf o rm a n ce .c om · ww w. CO RS A p e rf o rm a nc e.
Cat-Back Exhaust System Dual Rear Exit w/ 5.0” Straight Cut Tips 2017+ Ford F150 Raptor 3.5L EcoBoost PN 14397, 14397GNM, & 14397BPC CORSA Exhaust Installation Pictures: Fig. X Fig. Y Fig. AA Fig. Z Fig. BB INS5351 06/02/17 CORSA Performance · 140 Blaze Industrial Pkwy · Berea, OH 44017 · P: (440) 891.0999 · F: (440) 891-1868 E - Ma il : s al es @ C OR S A p e rf o rm a n ce .c om · ww w. CO RS A p e rf o rm a nc e.
