ICE DISPENSER Model D3030-1 Installation Manual Part No. 91718 Revised: August, 1995 THIS DOCUMENT CONTAINS IMPORTANT INFORMATION This Manual must be read and understood before installing or operating this equipment Ó IMI CORNELIUS INC; 1989-95 PRINTED IN U.S.
TABLE OF CONTENTS Page SAFETY PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 GENERAL DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 INSTALLATION INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SAFETY PRECAUTIONS Always disconnect power to the dispenser before servicing or cleaning. Never place hands inside of hopper or gate area without disconnecting power to the dispenser. Agitator rotation occurs automatically when dispenser is energized! This ice dispenser has been specifically designed to provide protection against personal injury and eliminates contamination of ice.
INSTALLATION INSTRUCTIONS 1. Locate the dispenser indoors on a level counter top. Unpack the four (4) legs and install them into the threaded holes provided in the bottom of the unit. 2. Connect the 3/4?IPS (or equal) drain line to the 3/4?threaded drain connections at the lower rear of the unit. This line must pitch downward to an open drain and must contain no traps, or improper drainage will result. 3. Clean the hopper interior. (See CLEANING INSTRUCTIONS.) 4.
D3030-1 MOUNTING TEMPLATE 1- 1/8-IN. 18 -1/2-IN. 30-IN. 3/8 DIA. 4 PLACES 27- 3/4-IN. 1 -1/8-IN. 30-IN. NOTE: Leg mounting holes ref. (5/16--18 threads) FIGURE 2.
CLEANING INSTRUCTIONS WARNING: DISCONNECT POWER BEFORE CLEANING! Do not use metal scrapers, sharp objects or abrasives on the ice storage hopper, top cover and the agitator disk, as damage may result. Do not use solvents or other cleaning agents, as they may attack the plastic material. DISPENSER 1. Clean the ice dispenser interior at least once a month. 2. Lift off agitator assembly and wash and rinse it thoroughly. 3.
DAILY or as required Remove foreign material from vending area sink to prevent drain blockage. WEEKLY or as required Clean the vending area. Check for proper water drainage from the vending area sink. MONTHLY Clean and sanitize the hopper interior. (See cleaning instructions). If the dispenser fails to dispense ice when operated, check that the hopper has ice in it and that power is being supplied to the unit. If the problem persists, check the following: 1.
TROUBLESHOOTING Should your unit fail to operate properly, check that there is power to the unit and that the hopper contains ice. If the unit still does not dispense, check the following chart under the appropriate symptoms to aid in locating the defect. Trouble Probable Cause BLOWN FUSE OR CIRCUIT BREAKER. GATE DOES NOT OPEN. AGITATOR DOES NOT TURN. GATE DOES NOT OPEN OR IS SLUGGISH. AGITATOR TURNS. GATE OPENS, AGITATOR DOES NOT TURN. ICE DISPENSES CONTINUOUSLY. SLUSHY ICE, WATER IN HOPPER.
ICE LEVEL SIGNAL GROUND L N OPTION T’ STAT 1 GRN LIGHT LIGHTED DISPLAY 2 OPTION WHT BALLAST BLK LIGHT BLK WHT WHT BLK STARTER WHT GATE SOLENOID 1 1/4 AMP TIME 24 V. RED TRANSFORMER KEY SWITCH BEVERAGE FAUCET OPTION (TYPICAL) DELAY FUSE WHT TERMINAL BOARD RED AGITATOR BEVERAGE SYSTEM MOTOR RED PORTION CONTROL OPTION TO TERMINAL BOARD { PORTION TIMER SW TD OR RED BLK DISPENSE DISPENSE SWITCH SWITCH WHT RED BLK SERVICE INFORMATION DANGER! ELECTRIC SHOCK HAZARD.
1 2 22 4 3 5 4 22 6 19 18 22 20 21 8 16 15 14 11 17 19 13 9 12 7 FIGURE 4. SOLENOID ASSEMBLY EXPLODED VIEW AND PARTS LIST Index No. Part No. Qty. Name 1 21493 1 2# 31551 1 Solenoid Mounting Plate Solenoid Service Kit 3 70171 2 8--32 x 3/8 Phil Tr HD Screw 4 70121 2 No.
PARTS LIST Item No. Part No.
IMI CORNELIUS INC. One Cornelius Place Anoka, MN. 55303--6234 Telephone (800) 238--3600 Facsimile (612) 422--3232 WARRANTY IMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workmanship under normal use and service. For a copy of the warranty applicable to your Cornelius product, in your country, please write, fax or telephone the IMI Cornelius office nearest you. Please provide the equipment model number and the date of purchase.
IMI CORNELIUS INC.
