Service manual

071329
Trouble RemedyProbable Cause
DISPENSED DRINKS HAVE
OFF’’ TASTE
A. Air tank contains excessive
water (condensation).
A. Drain condensation from air tank,
then sanitize syrup systems and
replace contaminated syrup.
AIR COMPRESSOR‘‘LONG
CYCLES’’
A. Condensation drain valve on
air tank is in ‘‘OPEN‘’ position.
A. Place condensation drain valve in
‘‘CLOSED’’ position.
B. Pressure relief valve on air
tank lid is open
B. Close air tank lid relief valve.
C. Air compressor air filter is
clogged.
C. Replace air compressor air filter.
D. Air tank lid not properly
installed.
D. Properly install lid on air tank.
E. Leak in air system lines and/or
regulators.
E. Check for leak in air line from
compressor to air tank, line from
air tank to air/CO change over
valve. regulator, lines to syrup
tanks. and line to shake machine.
F. Air compressor inoperative F. Replace air compressor.
WATER INLET PRESSURE
GAUGE READS TOO LOW
A. Water inlet valve in
‘‘CLOSED’’ position.
A. Place water inlet shutoff valve in
‘‘OPEN’’ position.
B. Water prefilter is clogged. B. Replace water prefilter.
C. Water pressure regulator is
incorrectly adjusted.
C. Readjust water pressure regulator
to 75 ± 5 PSI (5.17 ± .34 Bars).
D. Water pressure regulator
strainer is clogged.
D. Clean or replace water strainer
filter.
E. Water regulator inoperative. E. Call Service Technician.
WATER INLET PRESSURE
GAUGE READS TOO HIGH
A. Water pressure regulator is
incorrectly adjusted.
A. Readjust water pressure regulator
to 75PSI (5.17 Bars)
B. Water pressure regulator
inoperative.
B. Call Service Technician.
NOTE: Refer to manual provided with carbonator for troubleshooting information.