Service manual

143
20
Exploded Views and Serivce Parts
Outdoor Units
Ref
Part No. Description
Model Name
No. MM-A0160HX
1 43A00020 PLATE-SIDE (Right) 1
2 43A00021 PLATE-SIDE (Left) 1
3 43A00022 AIR-IN-CABINET Front) 1
4 43A00023 AIR-IN-CABINET (Back) 1
5 43A00024 CABINET-DOWN (Front) 1
6 43A00025 CABINET-DOWN (Back) 1
7 43A00026 SERVICE PANEL 1
8 43A00027 AIR-OUT-CABINET 1
9 43A20004 PROPELLER FAN – PY631 1
10 43A41513 COMPRESSOR – 6HP (Fixed) 1
11 43A49006 HIGH PRESSURE SWITCH 1
12 43A49007 ASM – PRESSURE – SENSOR (Low – Blue) 1
13 43A49008 ASM – PRESSURE – SENSOR (High – Red) 1
14 43A46019 ASM – SOLENOID COIL – 2-WAY (SV41 + SV42) 1
15 43A46020 ASM – SOLENOID COIL – 2-WAY (SV2 + SV3A) 1
16 43A46022 ASM – SOLENOID COIL – 2-WAY (SV3B) 1
17 43A46023 ASM – SOLENOID COIL – 2-WAY (SV3C) 1
18 43A46024 ASM – SOLENOID COIL – 4-WAY (J502 AC240V) 1
19 43A46025 COIL – PULSE MOTOR VALVE (L12A-03) 1
20 43A46026 COIL – PULSE MOTOR VALVE (A12A15) 1
21 43A46027 BODY – PULSE MOTOR VALVE (CEV30RC1) 1
22 43A46028 BODY – PULSE MOTOR VALVE (SEV18RC4) 1
23 43146499 VALVE BODY – 4-WAY (CHV-0401) 1
24 43046151 VALVE BODY – 2-WAY (NEV-603DXF) 3
25 43A46034 VALVE BODY – 2-WAY (VPV 360D) 2
26 43A48007 OIL SEPERATOR 1
27 43A48005 ACCUMULATOR (9 Litres) 1
28 43A48006 LIQUID TANK (11 Litres) 1
29 43A60013 FUSIBLE PLUG 1
30 43A43020 CONDENSER ASSEMBLY – RIGHT 1
31 43A43021 CONDENSER ASSEMBLY – LEFT 1
32 43A45003 DRYER – XH10 (R407C) 2
33 43146351 SERVICE VALVE (Gas) 1
34 43A46029 PACKED VALVE (Liquid) 1
35 43A46029 PACKED VALVE (Oil) 1
36 43A46031 CHECK VALVE (BCV – 302DY) Dia 8mm 3
37 43A46032 CHECK VALVE (BCV – 304DY) Dia 15mm 1
38 43A46035 CHECK VALVE (MP3.3MPaG) Dia 12.7mm 2
39 43A46036 CHECK JOINT (3.3MPa) 2
40 43147529 STRAINER (Dia 44mm) 1
41 43A47019 STRAINER (Dia 12.7mm) 3
42 43A47042 STRAINER (Dia 19mm) 1
43 43A57004 CRANK CASE HEATER (40W) 1
44 43A57002 ACCUMULATOR HEATER (29W) 1
45 43A51005 ISOLATOR (4 pole – 32 Amp) 1
46 43A21022 FAN MOTOR (STF – 200 – 350A) 1
47 43A42002 RUBBER COMPRESSOR MOUNTING 4
48 43A95001 RUBBER SUPPORT CUSHION (
Fan Motor Assembly )4
49 43A19011 FAN GUARD 1
50 43A46033 FLARE NUT (Oil circuit) 1
51 43A47043 CAPILLARY ASSEMBLY (1.0x2.0x1000 – Oil inlet) 1
52 43A47044 CAPILLARY ASSEMBLY (1.2x2.4x1000 – Suction) 1
53 43A47045 CAPILLARY ASSEMBLY (2.0x3.0x1000 – By-pass) 1
54 43A47046 CAPILLARY ASSEMBLY (1.2x2.4x1000 – Main oil) 2
55 43A47047 CAPILLARY ASSEMBLY (1.0x2.0x1000 – Discharge) 2
56 43A47048 CAPILLARY ASSEMBLY (1.0x2.0x1000 – By-pass) 1
57 43A16003 WIRING DIAGRAM 1
MM-A0160HX