Owner’s Manual for the cooktek thermacube™ food delivery system models tcs100 & tcs200 * part numbers: 609101, 6092xx CAUTION: Read the instructions before using the equipment. ©2016 TurboChef Technologies, Inc. *Delivery bags and natural convection trays sold separately.
For further information, call 800.90TURBO or +1 214.379.
Original Instructions The information contained in this manual is important for the proper installation, use, maintenance, and repair of this equipment. Follow these procedures and instructions to help ensure satisfactory results and years of trouble-free service. Errors – descriptive, typographic, or pictorial – are subject to correction. Specifications are subject to change without notice. Please carefully read this manual and retain it for future reference.
Table of Contents Safety Instructions Important Safety Instructions General Safety Information Grounding Instructions Power Cord Replacement i i ii ii Specifications and Installation Theory of Operation ThermaCube Charger ThermaCube Natural Convection Tray ThermaCube Delivery Bags Certifications Electrical Specifications Installation Unpacking Instructions Installing the ThermaCube Charger Assembling the Delivery Bag 1 1 2 3 4 4 4 4 4 4 Maintenance 5 Controls ThermaCube Charger Controls Operating the
i IMPORTANT SAFETY INSTRUCTIONS WARNING: When operating this appliance, strictly adhere to the following safety precautions to reduce the risk of burns, electric shock, fire, injury, damage to appliance or property near appliance. GENERAL SAFETY INFORMATION • • • • • • • • • • • • • • • • • • SAVE THESE INSTRUCTIONS safety instructions • Read all instructions before using this appliance. This appliance must be grounded. Connect only to a properly grounded outlet.
ii safety instructions • • • • • • • • • • Users wearing a pacemaker should consult their doctor or the pacemaker manufacturer prior to operating CookTek induction equipment. The electromagnetic field may interfere with the proper function of the pacemaker. The ThermaCube chargers and natural convection trays are intended for use with CookTek-designed and approved delivery bags only. DO NOT attempt to use unapproved or damaged delivery bags or natural convection trays.
1 13.63” (346 mm) 14” (356 mm) 16.93” (430 mm) 3.5” (89 mm) 8.25” (209 mm) 1” (25 mm) 13.88” (353 mm) 16.75” (425 mm) Figure 1: ThermaCube Charger Dimensions (Top and Side Views) Theory of Operation ThermaCube Charger The ThermaCube Food Delivery System uses precise induction technology to warm food without cooking or overheating. The speciallydesigned natural convection tray creates a blanket of warm air that surrounds the food, keeping it at a consistent, hot temperature for up to 45 minutes.
2 specifications and installation Figure 2: ThermaCube Natural Convection Tray Dimensions ThermaCube Natural Convection Tray ThermaCube Natural Convection Tray The ThermaCube natural convection tray is removable and designed to optimize food temperatures inside the delivery bag. The natural convection tray should be placed at the bottom of the delivery bag, directly under the food being held.
3 12.75” (324 mm) 10.25” (260 mm) 15.13” (384 mm) 13.38” (340 mm) Front Side Figure 3: ThermaCube Large Delivery Bag 13.38” (340 mm) 13.38” (340 mm) Front Side Figure 4: ThermaCube Small Delivery Bag ThermaCube Small Delivery Bag Available in two sizes, the ThermaCube delivery bags are equipped with the VaporVent™ system to effectively control moisture while keeping food warm.
4 specifications and installation Certifications The CookTek ThermaCube Food Delivery System has been tested and is in conformance with ANSI/ UL-197 and CSA C22.2 No. 109 standards and bear the commercially-rated approvals. Electrical Specifications The ThermaCube charger should be plugged into a grounded, single-phase receptacle. Check the rating plate on the unit to verify correct voltage and wattage. Voltages below 120 VAC or 240 VAC can result in less-than-rated power and slower heating times.
5 Maintenance Follow the steps below when cleaning your ThermaCube charger, natural convection tray, and delivery bag. Failure to adhere to these procedures may damage components, resulting in a non-warranty service call. Step 1: Turn the Charger Off and Allow to Cool • Turn the unit OFF by pressing the power button. • Remove the plug from any power outlets. DO NOT proceed to Step 2 until the charger surface is cool to the touch.
6 controls 4 1 2 3 Figure 5: ThermaCube Charger Controls ThermaCube Charger Controls 1. Ready LED This green LED will illuminate to indicate that the delivery bag is fully charged and ready for use. 2. Charge LED This red LED will illuminate to indicate that the delivery bag is charging. 3. Reset Button/LED Use this button to reset the ThermaCube charger in case an error occurs. This button can also be pressed to exit Sleep Mode (see page 7). 4.
7 Operating the ThermaCube Food Delivery System 1. Make sure that your ThermaCube charger is plugged in to a dedicated circuit. See page 4 for electrical specifications. 2. Press the Power button to turn the unit on. An LED will illuminate to indicate that the charger is on and ready for use (see page 6). NOTE: If the ThermaCube charger has not been used for an extended period of time, it will automatically enter Sleep Mode. Sleep Mode is indicated by two beeps and flashing Power LEDs.
8 troubleshooting Troubleshooting The following is a list of error codes, along with the possible problem(s) that the appliance may experience. Please attempt the recommended action before calling CookTek Tech Support (800.90TURBO, +1 214.379.6000) or your Authorized Distributor. Error Codes Error codes will be indicated by a number of beeps and the flashing Reset LED. Count the number of beeps in a row – this will be the error number.
9 Issue Possible Cause(s) Resolution No power (lights or fan noise). • • Unit unplugged. No power to receptacle. • • Plug unit in. Check wall switches/circuit breaker. Red Charge LED does not turn on when delivery bag is placed on charger. • No natural convection tray in delivery bag. Delivery bag is not positioned correctly. • • Foreign or metallic objects on top of the charger, between the charger and delivery bag, or inside of the delivery bag.
10 warranty THIS WARRANTY REPLACES AND SUPERCEDES ANY AND ALL PREVIOUS WARRANTIES OFFERED BY COOKTEK AND/OR ANY WARRANTIES PROVIDED IN THE ACCOMPANYING PRODUCT MANUAL Two (2) Year North America Limited Warranty for “Portable” CookTek Products CookTek Product Models Covered Under this Limited Warranty “Portable” CookTek products shall mean all Single and Double Burner Cooktops (countertop or built-in), Woks (countertop or built-in), FaHeaters, Soup Warmers, ThermaCube Delivery Systems, and Pizza Delivery S
11 Modifications and Repair: Equipment that has been modified or altered by persons other than CookTek or its service agents, or Equipment that has had non-approved devices or connection items attached thereto, is excluded from coverage under this warranty. Repair of the Equipment by anyone other than CookTek or its authorized service agents will void all warranties on the Equipment.
12 warranty Customer Indemnity You agree to indemnify, defend and hold CookTek harmless from all third party claims, demands, judgments, fees and costs directly or indirectly arising out of or related to your use of the Equipment. You further agree to indemnify and hold CookTek harmless from any incidental, consequential or special damages suffered by you, including lost revenue or profits, loss of use, or substitute use, during periods of Equipment failure or loss of use.
13 This page intentionally left blank.
For service or information: wi thin no r th a me r ica ca l l Customer Support at 800.90 T U R B O outsi d e no r th a me r ica ca l l +1 214.379.6000 or Your Authorized Distributor Part Number: CT-103930 / Revision A / October 2016 Country Code: NA/EU Global Operations Customer Support 2801 Tr ade Center Dr ive Carrollton, Texas 75007 usa +1 214.379.6000 phone +1 214.379.6073 fa x 800.90 T U R B O +1 214.379.6000 tur boch ef.
