GHS Safety Data Sheet C OR POR AT I ON Product Name: Congoleum SU‐106 Part A Seam Sealer Date Revised: 10/30/2015 Preparer: LGD Reviewer: TCG SECTION 1 – PRODUCT AND COMPANY IDENTIFICATION Product Name: Congoleum SU‐106 Part A Seam Sealer Manufacturer: Congoleum Corporation Address: 3500 Quakerbridge Road Mercerville, NJ 08619 800‐274‐3266 Emergency Phone: CHEM TEL at 800‐255‐3924 (24 Hours) Product Uses: Seam Sealer SECTION 2 – HAZARDS IDENTIFICATION GHS Label Elements: Classification: Hazar
GHS Safety Data Sheet C OR POR AT I ON Precautionary Statements: Keep out of reach of children; Read label before use; If medical advice is needed: Have product container or label at hand.
GHS Safety Data Sheet C OR POR AT I ON SECTION 4 – FIRST AID MEASURES Eyes: Flush thoroughly with water for at least 15 minutes. Hold eyelids apart to ensure flushing of entire eye surface. Remove contact lenses, if present and easy to do. Consult a physician immediately. Skin: Immediately flush with water for 15 minutes. Wash the contaminated skin with soap and water. If clothing becomes contaminated, launder before reuse. If irritation or pain develops, get medical attention.
GHS Safety Data Sheet C OR POR AT I ON SECTION 6 – ACCIDENTAL RELEASE MEASURES Personal Precautions: Wear appropriate protective equipment including self‐contained breathing apparatus. Do not touch or walk through spilled material. Do not touch damaged containers or spilled material unless wearing appropriate protective equipment. Emergency Procedures: As an immediate precautionary measure, isolate spill or leak area for at least 50 meters (150 feet) in all directions.
GHS Safety Data Sheet C OR POR AT I ON Additional Exposure Guidelines Tetrahydrofuran ACGIH STEL:250 pm, 737 mg/m3 NIOSH REL: 200 ppm, 590 mg/m3; NIOSH STEL: 250 ppm, 735 mg/m3 Toluene OSHA PEL Ceiling:300 ppm, 1,130 mg/m3 NIOSH REL: 100 ppm, 375 mg/m3 NIOSH STEL: 150 ppm, 560 mg/m3 Methylene bis (4‐cyclohexylisocyanate) NIOSH REL: Exposure Controls Eye Protection: Skin Protection: Ventilation: Respiratory Protection: Other Protective Equipment: Hygiene Practices: 0.01 ppm ceiling, 0.
GHS Safety Data Sheet C OR POR AT I ON SECTION 9 – PHYSICAL AND CHEMICAL PROPERTIES Appearance: Odor: Odor Threshold: Physical State: pH: Melting Point/ Freezing Point: Boiling Range: Flash Point: Evaporation Rate: Flammability (solid; gas): Upper/Lower Explosive Limits (% by volume of vapor): Oxidizing Properties: Vapor Pressure: Vapor Density: Specific Gravity or Relative Density: Solubility(ies): Water Solubility: Fat Solubility (solvent –oil to be specified): Partition Coefficient (n‐octanol/water): Vi
GHS Safety Data Sheet C OR POR AT I ON SECTION 12 – ECOLOGICAL INFORMATION Components of this product are toxic to aquatic life. Do not dump into waterways. SECTION 13 – DISPOSAL CONSIDERATIONS Disposal should conform to federal (40 CFR part 261), state, and local regulations. Before attempting cleanup, refer to hazard information and personal protection information in other sections of this SDS. If waste is determined to be hazardous, use licensed hazardous waste transporter and disposal facility.
GHS Safety Data Sheet C OR POR AT I ON SECTION 15 – REGULATORY INFORMATION OSHA: This product is considered hazardous as defined by 29 CFR 1910.1200 (OSHA Hazard Communication Standard.
GHS Safety Data Sheet C OR POR AT I ON Product Name: Congoleum SU‐106 Part B Seam Sealer Date Revised: 10/30/2015 Preparer: LGD Reviewer: TCG SECTION 1 – PRODUCT AND COMPANY IDENTIFICATION Product Name: Congoleum SU‐106 Part B Seam Sealer Manufacturer: Congoleum Corporation Address: 3500 Quakerbridge Road Mercerville, NJ 08619 800‐274‐3266 Emergency Phone: CHEM TEL at 800‐255‐3924 (24 Hours) Product Uses: Seam Sealer SECTION 2 – HAZARDS IDENTIFICATION GHS Label Elements: Classification: Flamm
GHS Safety Data Sheet C OR POR AT I ON Response: In case of fire, use dry chemical or alcohol type foam for extinction; If skin irritation or rash occurs, get medical advice/attention; Take off contaminated clothing and wash before re‐use; If eye irritation persists, get medical advice/attention; Rinse mouth; Call a POISON CENTER or doctor/physician if you feel unwell; IF ON SKIN (or hair): Remove immediately all contaminated clothing.
GHS Safety Data Sheet C OR POR AT I ON Most important symptoms/effects, acute and delayed as described below: Eye irritant. Isobutyraldehyde vapors (generated by contact of this material with Eyes: moisture/water) will irritate eyes. Skin: Skin irritant; May be absorbed through the skin in harmful amounts; May cause skin sensitization; May cause dermatitis.
GHS Safety Data Sheet C OR POR AT I ON SECTION 7 – HANDLING AND STORAGE Keep away from heat or ignition sources – No Smoking. Ground equipment when transferring from one vessel to another. Do not pressurize, cut, weld, braze, solder, drill, grind or expose containers to heat, flame, sparks, or other ignition sources. Do not enter confined spaces without following proper procedures. Avoid contact with skin and eyes.
GHS Safety Data Sheet C OR POR AT I ON SECTION 9 – PHYSICAL AND CHEMICAL PROPERTIES Appearance: Odor: Odor Threshold: Physical State: pH: Melting Point/ Freezing Point: Boiling Range: Flash Point: Evaporation Rate: Flammability (solid; gas): Upper/Lower Explosive Limits (% by volume of vapor): Oxidizing Properties: Vapor Pressure: Vapor Density: Specific Gravity or Relative Density: Solubility(ies): Water Solubility: Fat Solubility (solvent –oil to be specified): Partition Coefficient (n‐octanol/water): Vi
GHS Safety Data Sheet C OR POR AT I ON SECTION 12 – ECOLOGICAL INFORMATION Components of this product are toxic to aquatic life. Do not dump into waterways. SECTION 13 – DISPOSAL CONSIDERATIONS Disposal should conform to federal (40 CFR part 261), state, and local regulations. Before attempting cleanup, refer to hazard information and personal protection information in other sections of this SDS. If waste is determined to be hazardous, use licensed hazardous waste transporter and disposal facility.
GHS Safety Data Sheet C OR POR AT I ON SECTION 15 – REGULATORY INFORMATION OSHA: This product is considered hazardous as defined by 29 CFR 1910.1200 (OSHA Hazard Communication Standard.) SARA 313 Listing: This product does not contain any substances subject to this regulation. TSCA Inventory: The chemical substances in this product are on the TSCA Section 8 Inventory.
