USER'S INFORMATION, MAINTENANCE AND SERVICE MANUAL HIGH EFFICIENCY SEALED COMBUSTION GAS FURNACE MODELS: EDGAR and GALAHAD {Single Stage Down flow Only) re For Installation In: 1. Manufactured (Mobile) Homes 2. Recreational Vehicles 8 Park Models po 3 Modular Homes & Buildings a) DR 0 sage System TABLE OF CONTENTS CONTACT INFORMATION FOR USA...
128099-BUM-J-0112 8. NEVER. Si ore flammable materials of any kind near your furnace. Gasoline, solvents. and other volatile liquids should be stored only in approved containers outside your home. These materials vaporize easily and are extremely dangerous. 7. NEVER...Store cleaning materials near your furnace. Materials such as bleaches, detergents, powdered cleansers, eto, can cause commission of the heat exchanges. 8. NEVER...
128099-BUM-J-0112 GAS SUPPLY The gas supply to your home will either be Natural Gas or Propane gas. Your furnace will be factory equipped to operate on ably one of these two different gases. A small metal tag secured to the furnace next to the gas valve wil spec. ify the type of gas your fum ace is quipped to Use. if the gas is different from that specified on the metal tag, the furnace can be converted by following the Instructions on the furnace safety table inside lower front panel.
128099-BUM-J-0112 HOW YOUR GAS FURNACE WORKS Your fum ace is a very easy appliance to fake for granted. Season after season, it sits there in your home, keeping you warm and comfortable For this reason. you may never have given much thought fo the way your furnace operates. In order to get the safest and most efficient operation from your furnace, you should understand how your furnace does its job.
128099-BUM-J-0112 OUTLET (MANIFOLD) 7 MAIN REGULATOR PRESSURE TAP J | ADJUSTMENT FLANGE INLET opm SUPPLY PRESSURE : THe : nS , ELECTRICAL ON/OFF SWITCH “> CONNECTIONS {Shawn in OFF position) OUTLET FIGURE 4: (as Valve GAS Gs MANUAL Jean BURNER VALVE VALVE 7 DRIP LEG LEG FIGURE %: Gas Piping FURNACE USER MAINTENANCE Before proceeding, be sure the area is well ventilated Turn the thermostat OFF If the blower is tuning, wait until it stops automatically Turn OFF the gas and electrical power supplies fo the fur
1 28099-BUM-J-0112 SECTION II: SERVICE AND MAINTENANCE MANUAL SAFETY SECTION This section has been designed lo assist a qualified service agency in performing service and maintenance on this appliance. The homeowners landlord end user must never attempt fo perform any service or maintenance on the appliance especially when #t involves the removal or adjustment of any parts and/or components. The following safety rules must be followed when servicing the fum ace.
128099-BUM-J-0112 SEQUENCE OF OPERATION Continuous Blower On coaling/heating thermostats with fan switch, when the fan switch is stein the ON position, a circuit is completed between terminals R and G of the thermostat. The blower motor is energized through the cool fan terminal on the ignition control module. intermittent Blower .
128099-BUM-J-0112 FURNACE CONTROL DIAGNOSTICS The furnace has befit-in, self diagnostic capability. If a system problem occurs, a fault code is shown by a blinking green LED. It Is located behind a clear view port in the blower compartment door. DO NOT turn off furnace power as this action will dear the controls memory of the fault, The control continuously monitors its own operation and the operation of the system. If a failure occurs, the LED will indicate the failure code.
128099-BUM-J-0112 SECTION Ill: REPLACEMENT PARTS LIST All components, assemblies, accessories, and replacement parts for this fum ace are available through your qualified service installer of refer to the service center list in your booklet. it is not recommended that the homeowner purchase, install, of replace any components of this fum ace. Contact your local contractor, dealer, or service provider for additional information.
128099-BUM-J-0112 EDGAR ITEM [DESCRIPTION DGAAUSSBDTB AUTOBIOGRAPHER DGAAGT7BDTB DGAACSCBDTB Switch, Pressure S-32435872000 | S-32435972000 | S-32435972000 | $1-32435972000 Tubing Slickness (2 Reed) 51-02812488000 51-02812468000 S-02812489000 $1-02812498000 7 Cit Switch, Manual (Upper) $1-02535358000 51-02535358000 $1-02535356000 $1-02535358000 Assembly, Booster (motor] 81-37519801821 81-37518801821 51-37319B801821 S-37316801821 Control Board, Integrated £1-03101932002 £1-03101932002 51-03101932002 $1-03101
128099-BUM-J-0112 GALAHAD ITEM | DESCRIPTION DGAHO5E6BBSES DGAHO77BBSE | Switch, Pressure S-32435872000 $1-32435872000 Tubing Silicone (2° Reed) 51-02812499000 $1-02812409000 Limit Switch, Marla (Upper) £1-02535358000 $1-02535358000 Assembly, Booster (motor) 5137318801821 $51-37318801821 Control Board, integrated 8103101832002 $1-03101932002 Valve.
Limited Warranty For Manufactured Housing Furnace UPG warrants this product 10 be free from deficits in factory workmanship and material under normal use and service and wil replace pants that prove to have such defects according to the terms outlined below.
