Propane Catalytic Heater INSTRUCTIONS FOR USE U.S. and other Patents Pending © 2003 The Coleman Company, Inc. www.coleman.com IMPORTANT Read this manual carefully before assembling, using or servicing this heater. Keep this manual for future reference. If you have questions about assembly, operation, servicing or repair of this heater, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. In Canada call 1-800-387-6161. Model 5034 Propane Series CAN1-11.
Warning Contents General Safety Information To Set Up To Light To Turn Off To Store Things You Should Know Replacement Parts List Warranty General Safety Information FOR YOUR SAFETY If you smell gas: 1. Do not attempt to light appliance. 2. Extinguish any open flame. 3. Disconnect from fuel supply. FOR YOUR SAFETY Do not store or use gasoline or other liquids with flammable vapors in the vicinity of this or any other appliance.
General Safety Information cont. DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate personal injury, or property damage.
General Safety Information cont. WARNING • This product is fueled by propane gas. Propane gas is invisible, odorless, and flammable. An odorant is normally added to help detect leaks and can be described as a “rotten egg” smell. The odorant can fade over time so leaking gas is not always detectable by smell alone. • Propane gas is heavier than air and leaking propane will sink to the lowest level possible.
To Set Up NOTE: Use 16.4 oz disposable propane cylinders only. Do not connect to bulk propane systems. The LP-gas cylinder(s) used with catalytic heaters must be constructed and marked in accordance with the specifications for LP-gas cylinders of the U.S. Department of Transportation or Transport Canada, CAN/CSA B339. ■ Unit includes Heater Assembly, Regulator Assembly, and Support Leg. Propane tank is not included. Heater ■ Unhook Brace. Insert wire in receiver hole.
To Set Up cont. To Light ■ Turn HEATER VALVE to OFF. DANGER • EXPLOSION - FIRE HAZARD ■ Attach CYLINDER to HEATER outdoors. • Propane is heavier than air and can accumulate in low places. If you smell gas, leave the area immediately. • Always attach or detach propane source outdoors; never while heater is lighted, near flame, pilot lights, other ignition sources or while heater is hot to touch. • This heater is red hot during use and can ignite flammables too close to the burner.
To Light cont ■ Hold match as shown. Turn valve to LIGHT position and hold for 8-10 seconds. ■ Heater will ignite with a brief visible flame. Continue to hold VALVE at LIGHT position for an additional 10 seconds. Release knob. It will return to ON position. Heater is NOT adjustable. ■ NOTE: Heater is designed to be lit with the valve fully open until it reaches full output. Observe heat build up for a few minutes to ensure heater is lit.
To Store Things You Should Know cont ■ Make sure Heater is cool. ■ Take unit outdoors away from any ignition sources. Remove Cylinder from Heater. ■ Replace plastic cap on cylinder. ■ Store propane cylinder consistent with the instructions and warnings on the cylinder. ■ The Support Leg is removable for storage. Support Leg ■ The regulator is removable for storage. Heater Regulator 8 1. This is a catalytic heater.
Replacement Parts List No. Part No.
Warranty Coleman Limited Five-Year Warranty Coleman will repair or replace, at its option, this product or any component found to be defective in materials or workmanship within five years of the original retail purchase. This warranty is valid for the original retail purchaser from the date of initial retail purchase and is not transferrable. Keep the original sales receipt. Proof of purchase is required to obtain warranty performance.
The Coleman Co., Inc. • 3600 N. Hydraulic • Wichita, KS 67219 U.S.A. 1-800-835-3278 • TDD: 316-832-8707 Sunbeam Corporation (Canada) Limited • 5975 Falbourne Street Mississauga, Ontario, Canada L5R 3V8 • 1 800 387-6161 ©2003 The Coleman Company, Inc. All rights reserved. Coleman® is a registered trademark of The Coleman Company, Inc. ©2003 The Coleman Company, Inc. Tous droits réservés. Coleman® est une marque déposée de The Coleman Company, Inc. ©2003 The Coleman Company, Inc.
